2003-2011 honda element spark plug replacement...2003-2011 honda element spark plug replacement...

of 10 /10
2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd. Replacing with factory recommended NGK Iridium spark plugs. 作成者: Niklas Johnson 2003-2011 Honda Element Spark Plug Replacement 下書き2016-02-19 ガイド ID: 7645 - ã“ã®æ–‡æ›¸ã¯2019-09-30 10:51:33 PM (MST)ã«ä½œæˆã•ã‚Œã¾ã—ãŸã€‚ © iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分ã®1ページ目

Author: others

Post on 10-Jul-2020

1 views

Category:

Documents


0 download

Embed Size (px)

TRANSCRIPT

Page 1: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

2003-2011 Honda Element Spark PlugReplacement

Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd.Replacing with factory recommended NGK Iridium spark plugs.

作成者: Niklas Johnson

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮1ページ目

Page 2: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

はじめにはじめに

This is a relatively easy job, the fastening bolts are all located on top of the engine. The coilpackconnectors are easy to disconnect without damaging anything, and the spark plugs themselves arenot difficult to replace.

Note: This service requires that the battery is disconnected, meaning that the factory radio willrequire its code to be reentered. Do not perform this service without the code, a dealer would haveto re-enable the stereo's functions

ツールツール:10mm Socket (1)3/8 inch Drive Socket Ratchet Extension (1)5/8" Spark Plug Socket (1)

5/8" spark plug socketthin-wall special purpose 5/8" deep socket withcapture for removing/installing spark plugs.

Socket Wrench (1)

部品部品:NGK IZFR6K11 spark plug (1)Dielectric Paste Compound (1)Anti-Seize Compound (1)

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮2ページ目

Page 3: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 1 — spark plugs

Pull hood latch release, located onthe base of the A-Pillar.

Pull up on the release lever betweenthe hood and grille, it is located onthe left.

Lift hood and engage the hood proprod inside the provided notch holeon the edge of the hood.

手順手順 2

Disconnect negative (-) batteryterminal from the battery.

Place the now free negative (-)battery cable behind the batteryitself so it cannot easily re-connectitself.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮3ページ目

Page 4: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 3

Remove the 4 10mm acorn nutsfrom the plastic engine cover plate.Set nuts aside for reassembly.

Remove the plastic coverplate andset aside.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮4ページ目

Page 5: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 4

Using the 10mm socket and ratchet,remove the 4 bolts holding down thecoilpacks. You may need the 10mmwrench if your socket is not deepenough to contact the hex section ofthe stud.

手順手順 5

Pull up on coilpack lightly, it shouldrelease easily from the spark plugbelow.

Using your thumb and forefinger,grasp the connector, pushing downthe latch with your thumb.

Wiggle and pull the connector off ofthe coilpack, it will have someresistance.

If the connector does not release, trypushing connector in, then pushingthe latch and pulling on theconnector.

Note: Do not pull by the wires.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮5ページ目

Page 6: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 6

Remove all the coilpacks and setaside.

Using the 3/8" Ratchet with SocketWrench Extension, 3/8" Drive and5/8" Spark Plug socket, remove the4 spark plugs from the spark plugwells. They should require someforce but unscrew easily after theinitial turns.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮6ページ目

Page 7: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 7

Remove new spark plugs from box.Apply anti-seize to the spark plugthreads ONLY, carefully wipe offany excess that touches the ceramicinsulator or the tip contact.

Now apply dielectric grease to thecontact tip and the first 1/2" of theceramic insulator.

手順手順 8

Using the spark plug socket, puteach spark plug into their hole andthread in hand tight.

Tighten all 4 plugs 1/2 turn pasthand tight.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮7ページ目

Page 8: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 9

Reinstall the coilpack 3/4 of the wayinto the hole, then push on theelectrical connector until it clicks.

Push the coilpack down the rest ofthe way into the spark plug well, youshould feel a slight click as thecoilpack connects to the contact ofthe spark plug

Repeat these same steps for theremaining 3 coilpacks.

手順手順 10

Using the 10mm socket and 3/8" ratchet, install bolts on the #1 (from left) and #3 coilpack. Theyshould be 1/4 turn past finger tight.

Install the studs on #2 and #4 coilpacks.

Reinstall coilpack cover, using the 4 acorn nuts removed previously.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮8ページ目

Page 9: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

手順手順 11

Reinstall the negative (-) batteryterminal, tightening with the 10mmwrench or 10mm ratchet.

手順手順 12

Remove hood prop rod from thehood, flip down and connect it intoits stay.

Shut hood lightly, then push down toengage the main latch.

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮9ページ目

Page 10: 2003-2011 Honda Element Spark Plug Replacement...2003-2011 Honda Element Spark Plug Replacement Doing the scheduled 110,000mile spark plug replacement on a 2005 Honda Element 4wd

This is a great job to do to save some money, its involved enough to be entertaining but not enough tobe scary.

手順手順 13

Using the code written in yourService History booklet (the Pre-Delivery Inspection page shouldhave it), key in the radio code usingthe preset buttons.

Don't forget to mark down that youserviced the spark plugs in theService History booklet!

2003-2011 Honda Element Spark Plug Replacement 下書き: 2016-02-19ガイド ID: 7645 -

㠓㠮文書㠯2019-09-30 10:51:33 PM (MST)ã «ä½œæˆ ã •ã‚Œã ¾ã —ã Ÿã€‚

© iFixit — CC BY-NC-SA jp.iFixit.com å…¨10 ページ分㠮10ページ目