219 mod 1-2 component location (wff-js) 08-22-02
TRANSCRIPT
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
1/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-021
Ob ective:
Vehicle and tools required:
Instructions:
At the conclusion of this module, you will be able to:
Locate electrical components on the vehicle.
Locate CAN connectors on the vehicle.
W211 (E500 with appropriate panels removed)
Flashlight
Required material:
1. Follow the instructions and answer the questions.2. Ask your instructor if assistance is needed.3. Stop at instructor check points for sign-off.
Name ______________________
XSkill Module Number: 1-2
Subject: Component Location
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
2/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-022
On the following pages, youll locate components on the vehicle. Match the calloutson the photos to the labeled components on the vehicle. The location areas of thecomponents are indicated above each picture.
Left Rear of Engine Compartment
A. ( ) Heat exchanger shut-off motor_______________________
B. ( ) Multi-function sensor_________________________ _____
C. ( ) ESP, SPS and BAS control module___________________
D. ( ) Driver-side signal acquisition and actuation module (SAM)_
E. ( ) ME-SFI control module_____________________________
F. ( ) Body acceleration sensor___________________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
3/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-023
Right Front of Engine Compartment
A. ____Filter screens only on the E320________________________________
B. ( ) Sensotronic Brake Control (SBC) hydraulic unit__________
C. ( ) Sensotronic Brake Control (SBC) control module_________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
4/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-024
Right Rear of Engine Compartment
A. ( ) Auxiliary battery____________________________ ______
B. ( ) Auxiliary battery relay______________________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
5/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-025
Under Dash Right
NOTE: This photo illustrates the location of the component, which is locatedunderneath the dash pad.
A. ( ) Solar generator control module______________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
6/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-026
Passenger Footwell Area
NOTE: This photo has been taken by unbolting and folding down a false floor in thepassenger footwell. In addition, carpet and glove box have been removed.
A. ( ) Semi-active air suspension control module (only location) _
B. ( ) Passenger side SAM______________________________
C. ( ) Transmission control module________________________
D. ( ) Front pre-fuse box________________________________
E. ( ) Cockpit CAN B connector__________________ ________
F. ( ) Right CAN B connector__________________ __________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
7/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-027
Passenger Seat Area
Fold the carpet back to view the labeled components.
A ( )_Yaw and lateral acceleration sensor_______________ ___
B. ____Location of vehicle identification number stamping__________________
C. ( ) Distronic control module_______________________ ____
D. ( ) Right side crash sensor____________________________
E. ( ) Headlamp range adjustment__________________ ______
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
8/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-028
Right Seat Back Area
A. ( ) Tow sensor______________________________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
9/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-029
Right Side of Trunk Area
A. ( ) Battery control module______________________ _______
B. ( ) Systems battery____________________________ ______
C. ( ) Rear pre-fuse box_________________________________
D. ______Semi-active air suspension pressure reservoir____________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
10/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-0210
Center Area of Trunk
A. ( ) Microphone control module (AKG) (standard equip.)_____ _
OR
( ) Voice recognition control module (Temic) (optional equip.)_
B. ( ) Communications platform control module (CP)_________ _
C. ( ) Telephone antenna splitter______________________ ____
D. ( ) Linear compensator________________________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
11/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-0211
Left Area of Trunk
NOTE: Item A listed below is located behind the trunk spring.
A. ( ) Audio Gateway (AGW)______________________________
B. ( ) Parktronic control module______________________ _____
C. ( ) Rear signal acquisition and actuation module____________
D. ( ) Tire pressure monitoring control module________________
E. ( ) Pneumatic pump for dynamic seat control_______ _______
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
12/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-0212
Left C-Pillar Area
A. ( ) Left antenna amplifier module________________________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
13/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-0213
Left Door Sill Area
A. ( ) Left CAN B connector (brown/red wire)___________ _____
B. ( ) MOST connector (pink wire / electrical wake-up line)_ ____
C. ( ) Engine CAN C connector (green/white wire)_________ ___
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
14/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-0214
Under Dash Left
NOTE: This photo illustrates the location of the component, which is locatedunderneath the dash pad.
A. ( ) DC / DC converter for Heated Steering Wheel__________
-
8/14/2019 219 Mod 1-2 Component Location (WFF-JS) 08-22-02
15/15
219 Mod 1-2 Component Location (WFF-JS) 08-22-0215
Left Bottom Area of Dash
A. ( ) Fuse box________________________________________
B. ( ) Central Gateway (CGW) control module________ _______
NOTE: The fuse chart is located in the fuse box shown above.
If you have noticed any parts that need to be replaced on this vehicle, please informyour instructor now.
Instructor check point ______________