2830100 10

2
DOW CORNING ® 732 Multi-Purpose Sealant General purpose silicone adhesive/sealant specified) APPLICATIONS " General industrial sealing and bonding applications. " Complies with MIL-A-46106 and FDA 177.2600. TYPICAL PROPERTIES Specification writers: These values are not intended for use in preparing specifications. Please contact your local Dow Corning sales representative prior to writing specifications on this product. CTM* ASTM* Property Unit Value As supplied 0176 Appearance Non-slump paste Colors) White, black or clear 0364 Extrusion rate 1 g/minute 350 0098 Skin-over time minutes 7 0095 Tack-free time minutes 20 Mechanical properties, cured 7 days in air at 25ºC 77ºF) and 50% relative humidity 0097B D1475 Specific gravity 1.04 0099 D2240 Durometer hardness, Shore A 25 0137A D412 Tensile strength MPa 2.3 0137A D412 Elongation at break % 540 0420 Volume coefficient of thermal expansion 1/K 1.12x10 -3 Electrical properties, cured 7 days in air at 25ºC 77ºF) and 50% relative humidity 0114 D149 Dielectric strength kV/mm 21.6 0112 D150 Dielectric constant at 100Hz/100kHz 2.8 0112 D150 Dissipation factor at 100Hz/100kHz 0.0015 0112 D150 Volume resistivity Ohm.cm 1.5x10 15 1. Extrusion rate: 3.2mm orifice at 0.62MPa. * CTM: Corporate Test Method, copies of CTMs are available on request. ASTM: American Society for Testing and Materials. HOW TO USE Substrate preparation All surfaces must be clean and dry. Degrease and wash off any contaminants that could impair adhesion. Suitable solvents include isopropyl alcohol, acetone or methyl ethyl ketone. Unprimed adhesion may be obtained on many substrates such as glass, metals and most common engineering plastics. Substrates to which good adhesion is normally not obtained include PTFE, polyethylene, polypropylene and related materials. d c Product Information FEATURES " One-component adhesive/sealant " Cures at room temperature when exposed to moisture in the air " Acetoxy cure system " Non-sag, paste consistency " Easy to apply " Cures to a tough, flexible rubber " Good adhesion to many substrates " Stable and flexible from -60ºC -76ºF) to +180ºC 356ºF), with short peaks up to +205ºC 401ºF) " Black version: stable and flexible from -60ºC -76ºF) to +205ºC 401ºF), with short peaks up to +230ºC 446ºF) " Excellent dielectric properties " Complies with MIL-A-46106 " Complies with FDA 177.2600 " Available in white, black or clear

Upload: trade-tools

Post on 30-Mar-2016

216 views

Category:

Documents


3 download

DESCRIPTION

http://tradetools.co.nz/webimages/2830100-10.pdf

TRANSCRIPT

��� ������� �� ������������ �������

������� ������� �������� �������� ������� !�����"���#

$��%��$&����� ������� �������� ������ ��� ������ ������������� ������� ���� ����������� ��� � � �!!�"����

&'���$% ����(�&�(�#����$������� ������% &��� '��� ��� ��� �������� $�� � �� ��������� ����$��������(���� ������� )�� ����� �� ������� ��� �����������'� ����� �� ������� ����$������� ����� �������

�& ) $�& ) �������* +��� ,����

$� ��������

��!� ���������� *������ ����

�����+, -����. ���/ �������

�0�� 12����� ����� �3����� 04�

��56 #/����'�� ���� ����� !

��54 &��/�$��� ���� ����� "�

��������� ����������- ����� ��*� �� ��� �� �./� !/0# ���.12 �������� ��3����*

��5!7 ��!4 #����$�� ���'��) ����

��55 ""�� ������� ������. #���� � "4

��0!� ��" &����� ������� �(� "�0

��0!� ��" 1��������� �� ���/ 8 4��

��"� 9���� ���$$������ �$ ��������2������

�3: ���"2���0

(��������� ����������- ����� ��*� �� ��� �� �./� !/0# ���.12 �������� ��3����*

���� ��5 ��������� ������� /93�� "���

���" �4� ��������� ������� �� ���;<3���/;< "�6

���" �4� �������� $����� �� ���;<3���/;< �����4

���" �4� 9���� �����'��) =����� ��42���4

�� 12����� ����% 0�"�� ���$��� �� ���"�(��> �&�% ��������� &�� ������. ����� �$ �&� ��� �'���� �� �� ��?����#&�% �������� #�����) $�� &����� ��� ���������

4�� &� +�(��5������ �������������� �$��� �� � ����� ��� ��)� ������ ��� ��� �$$ ��)����������� ���� ���� �������������� #��� �� ��'��� ������������)� �������. ������� �� ����)����)� /������

@������� ������� ��) � � �������� ���) ����� �� � ���.����� ��� ��� ������ ������������������ # ����� �� ����� ����������� � �������) ��� � ������������ (&�1. ���)���)����.���)����)���� ��� ������� ���������

��������� ��"��3�����

0($&+�(�

� =������������ �����'�3������� ��� �� ���� ���������� ���� �2������ ������ �� ��� ���

� �����2) ��� )���� *�����. ���� ��������)� 1�) �� ����)� ��� �� � ����. $��2� �� � ��� ���� ������� �� ���) ������ #�� �� ��� $��2� �� $������A� +�!�A�, �� B�6�A� +04�A�,. �������� ���/ � �� B"�4A� +���A�,

� 7���/ '�����% �� �� ��� $��2� �� $������A� +�!�A�, �� B"�4A� +���A�,. �������� ���/ � �� B"0�A� +���A�,

� 12������� ���������� ���������� ������� ���� ������������ ������� ���� � � �!!�"���� �'���� �� �� �����. ���/ �� �����

;���'��. $�� ��2��� �������. ���� �$ =- �=C*�*�D �"�� =#(����� � ������������ �$��� ��'�����������. � ���� ���� �$ =- �=C*�*� �"�� =# (����� �������� ) �������. ����� �����)���� ����� ������ �� ��) $�� �4 ��5� ����� �� ���� ���������� ��� �������'� ������) �$ 4�8 �� �������

4�6 �� ����*����) =- �=C*�*� !0" �����(���� #������ �� ��� �$ ��� ���������$���. ���� ?��/�) ��'�� ���� �������� ����� �� � ������

=� �2���� �� ������. ��� $����)������� �������� ���� E/����'��E� ��)������� ���� � ��������� �$��� ���/�� $���� &�� �$��� � ����) ���������� � ������ &�� �����'�3#���������� � ���/�$��� �� �� �����4 ������

���� ��3��$��� /�� $��������. ��� ������������� $��� ��� �$���� �� "� ���+�� ���� ���������� ��� 4�8 ������'�������), =- �=C*�*� !0"�����(���� #������ ���� ��� �� ������ �$ � �� 0��� 9��) ����������. ��������) ���� ���� ������������ ������ � ��������� ������/� ������ �� ��� ���������)� ������� � �2������ �� ����� ������)��'���

7�$��� �������� ��� ���/����� ��������������. �� ��� ��'��� �� ���� �$$�������) ���� ���� �� ���� ���� �����������) �$ ��� �����'� ��� � ����$$������ &�� ���� ������ �� ���)$����� ��� ���� � ���������� )��� �� $�� ���� ����$�� ������������

��3����5����* =- �=C*�*� !0" �����(����#������ ������ � ���� ����� �$������ ���� ����� ���� &�� ��) ����������� �� ��� �������� ���� �� �����. ��������) �� ������ ��������� ���� ��� ��� � ������� �� �� �������) ������� ���$�������� ��������� ��� ����� ��� )������� ��������

4$��%��� ��(�$+&����(����� �$��) ��$�������� ��?���� $���$� � � ��� �������� 7�$�����������. ���� ������ ��� �$��) �������� ��� ��������� �� �� $�� �$� �.��)���� ��� ������ ��<��� ��$���������&�� �������� �$��) ���� ���� ��'���� �� �� ��� �� ������� �� ����� ������������������� F� ��� ���� ���� � ���) $��� )�� ����� �� ������� ��� �����������'� �� ���� ��� �� ) ������� )�� ����� �� ������� ��� �� �����������

+�$7%( %�0( $���&��$�(-��� ����� �� �� ���� 0"A� +5�A�, ����� �������� ������� ���������. ��������� �� � � �� ��$� �$ "! �����$��� ��� ���� �$ ����������

� =- �=C*�*� !0" �����(���� #������ ��� ) �������� ���������� �� ���. /��� ��� ���������������) ����� ���� ��� �� �� � ����$ �� �������� ��) $��� �� ��� ��� �$� � � �� ��������� ����� ������� &��� ����) ����'�� ��� ��� ��� �$$������ ��������� ��������

�$�8$����&�� ������ � �'���� �� �� � '�����) �$��������� �<�� ������� )�� ����� �� ������� ��� �����������'� $����$�������� � �� ��������� �<��'���� �� �� )�� �����

%� �&$&����&�� ������ � ������� ����� ������������� � ��� �� $�� ������� ��������������� ��

4($%&4 $��(�,���� (�&$%��0�� $&���&� ����� ������ �� ����� �������$��) ����. �� ������� �� ���2����'� (����� #���������������<����� ��� � ���� �$ (�����#�$��) ��� C�������) ����������+(#GC�, �������� �'���� �� �� ���������

��� $����� ��$��������. ����� �� ���� ���. ������������������ ������� )�� ����� �� ������������������'��

%� �&(� �$��$�&'��0�� $&��� � �%($�(�($� �$�(0+%%'&�� ��$�������� ��������� ������ ��$$���� �� ���� $���� ��� � ����'�� �� � �������� ;���'��. ������������� ��� ������ �$ � �$ �������� ��� �)��� �� �������. �����$�������� ���� ��� � �� �� ������� $�� ������H ��� ������ ���� �� �������H ������ ����$�. �$$����'�. ��� $��) ���$�����)$�� ��� �������� ��� �� #��������$ � ���� ��� � ��/�� ���������� �� ��$����� ��) �������

�� �������H ��� �������) � ���� ��������� ���� ���� ��� �� ���������� ����$������� �� �$$��� �� ��� �����$ ��������

F�� �2���'� �����) $�� ����� �$�� �������) � ������� �� ��$�� �$������ ����� �� ����������� �$ ��)������ ���� �� � ����� ���� �����������

��� ������� ��(��0��$%%'����%$� � $�' �&4(�(9��(�� �� � �%�(��$��$�&' �0 0�&�(�� 0�� $�$�&��+%$� �+����( �� (��4$�&$7�%�&':

��� ������� ����%$� �%�$7�%�&' 0�� $�'�����(�&$% ������(;+(�&�$% �$ $�(�:

-1 ;1�( F=@ �*91*& &;1�@&@C1��

666:��6������<:��3

=- �=C*�*� !0" �����(���� #������ -1 ;1�( F=@ �*91*& &;1 �@&@C1� � � ��������/ �$ �� ������� ������������

" �43�43"��" =- �=C*�*� � � ��������� ��������/ �$ �� ������� ������������

C�$� ��� �����5����� � 0054 I�55!�"��" �� ������� ������������ ��� ����� ����'���