selection guide for tantalum electrolytic capacitor …编带符合eia481-1标准。 molded , smt...
Post on 26-Dec-2019
18 Views
Preview:
TRANSCRIPT
宁夏星日电子有限公司NINGXIA XINGRI ELECTRONICS CO., LTD
钽电解电容器Selection Guide For Tantalum Electrolytic Capacitor
R
选型指南2013版
●温度范围:-55℃ ~+105℃(大于85℃时使用降额电压) ;
●电容量偏差:±20%(其它容量偏差按用户要求提供) ;
●室温漏电流、损耗、等效串联电阻(ESR):见表4 ;
●电容器高低温特性:见表2 ;
●外形图、壳号尺寸:见图1和表1 ;
●额定电压、电容量:见表3。
主要技术性能
CA49型聚合物电解质片式钽电容器CA49 series Polymer Solid Electrolyte Tantalum Chip Capacitor
正极端视图Anode(+)End view
侧视图Side view
负极端视图
Cathode(-)End view
底部视图Bottom view
W
H
S SL
W1
电容器外形图 Figure 1 Outline Drawings
o p22710V
壳号Case size
D
L W H S W1
7.3 0.3± 4.3±0.3 2.8±0.3 1.3±0.3 2.4±0.1
EIA代码EIA code
(0.287±0.012) (0.169±0.012) (0.110±0.012) (0.051±0.012) (0.094±0.004)7343-31
表2 电容器高低温特性 Table2 Temperature characteristics
电容量变化(%)Cap.change
-55℃ +85℃ +105℃
损耗最大值(%)
DF Max.
-55℃ +25℃ +85℃ +105℃
漏电流最大值(μA) DCL Max.
+85℃ +105℃
±20 ±20 ±30 10I 12.5I0 0
-1.0 -0.5※ Capacitance and DF measured at 0 电容量、损耗测试条件 U =2.2 V, (有效值);测量频率 frequency:120Hz。-
0 U =1.0 V RMS~
漏电流应在施加额定电压5分钟后测量,+105℃时应施加降额电压。DCL is measured at rated voltage after 5 minutes, d is applied at + 0 ℃ ※ erating 1 5
图1
特点与用途
Features and Application
●模压封装、表面贴装 、聚合物固体电解质、极性电容器;
●体积小、低等效串联电阻(ESR)、高频特性好 ;
●电性能优良稳定、 可靠性高、寿命长、贮存稳定性好 ;
●符合欧盟RoHS和REACH法规的无铅要求 ;
●用于通讯、计算机、摄像机、移动通讯等领域 ;
●执行标准EIA-535BAAC-A,等同于KEMET公司T520系
列产品 ;
●编带符合EIA481-1标准。 ● Molded , SMT mounting, polymer as solid electrolyte,
polar capacitor ;
● Small size,low ESR,good frequency performance ;
● Excellent and stable electrical performances,high reliability,
long life, good shelf stability ;
● Lead-free terminals in compliance with RoHS and REACH
regulations ;
● Used for telecommunications, computer, camcorder, mobile
phone, etc ;
● Applicable specification EIA-535BAAC-A, equivalent to
KEMET T520 series ;
● Taping and reeling per EIA481-1 Spercification.
● Operating temperature range:-55℃-+105℃(>85℃
with rated voltage derating) ;
● Capacitance tolerance:±20% ;
● DC leakage, dissipation factor and ESR at 25℃:
see Table4 ;
● Temperature character ist ics:see Table 2 ;
● Outline drawings, case size and dimensions:see
Table 1,Figure 1 ;
● Rated voltage and capacitance:see Table 3.
Technical Specification
单位 Unit:mm (inches)表1 壳号尺寸 Table1 Case and dimensions
31
R
B 3.5 0.2± 2.8±0.2 1.9±0.2 0.8±0.3 2.2±0.1(0.138±0.008) (0.110±0.008) (0.075±0.008) (0.031±0.012) (0.087±0.004)3528-21
V 7.3 0.3± 4.3±0.3 2.0max 1.3±0.3 2.4±0.1(0.287±0.012) (0.169±0.012) (0.079) (0.051±0.012) (0.094±0.004)7343-20
见表4损耗 见表4损耗小于1.2倍表4损耗
小于1.5倍表4损耗
CA49 107 M 010 D
系列名称 容量 容量偏差 额定电压 壳 号
M:±20%004:4V
006:6.3V
010:10V
016:16V
XR
企业代码Company logo Series Capacitance Tolerance Rated voltage Case size Packing
T
B:3528-21
D:7343-31
V:7343-20
ESR Max.
0120
ESR最大值
10
22
33
47
68
100
150
220
330
470
106
226
336
476
686
107
157
227
337
477
容量代码Cap code
4(G)
2.5
5
6.3(J)
4
8
10(A)
6.3
13
壳号 Case size
电容量
C (μF)R
Capacitance
额定电压 U ( V)R
vRated oltage
降额电压 U ( V)C
Derating
浪涌电压 U ( V)S
vSurge oltage
D/V
D/V
D
CA49型聚合物电解质片式钽电容器CA49 series Polymer Solid Electrolyte Tantalum Chip Capacitor
贴片
型聚
合物
固体
电解
质钽
电容
器
包装方式
T:7"卷盘
7"Reel
S:13"卷盘
13"Reel
详见表4
See table 4
容 量 用 皮 法 拉 表 示 ,前两位数字是有效数字,第三位数
字是跟随零的个数。
Capacitance code: expressed in picofarad
two digits represent significant figures and
digit represents munltiplier(number of
zeros to follow).
, the
first
the third
CA49系列编码示例 Numbering system for CA49 series
表3 CA49系列电容量、额定电压和壳号 Table3 Capacitance and rated voltage by case size
※ 所有技术数据在25 下测量。All technical data relates to an ambient temperature at +25 .0 0 ※ 电容量和损耗测试条件Capacitance and DF measured at:U =2.2 V,U =1.0 V RMS(有效值 );测量频率 frequency:120Hz。- ~
※ 漏电流应在施加额定电压5分钟后测量,+105℃时应施加降额电压。DCL is measured at rated voltage after 5 minutes, and derating is applied at +105℃ ※ M代表容量偏差 refer to tolerance M:±20%。#代表包装方式 # refer to packing T:7" reel,S:13" reel。
℃ ℃
-0.5 -1.0
32
R
16(C)
10
20
B
B
B
D/V
D/V
D
B
B
B
V
D/V
D/V
D
D
B
B
V
D/V
D/V
D
D
+25℃ +85℃ +105℃
V
V
D
D
V
V
D
D
D
D
4
4
4
4
4
4
4
4
4
4
220
220
220
220
330
330
330
330
470
470
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
40
50
40
50
40
50
40
50
40
50
88.0
88.0
88.0
88.0
132.0
132.0
132.0
132.0
188.0
188.0
1.8
1.6
1.9
1.7
1.8
1.6
1.9
1.7
1.9
1.7
1.6
1.4
1.7
1.6
1.6
1.4
1.7
1.6
1.7
1.6
1.1
1.0
1.3
1.1
1.1
1.0
1.3
1.1
1.3
1.1
额定电压Rated
voltageU (V)R
电容量Capacitance C (μF)R
壳号Case size
漏电流DCL(μA)
Max.
损耗DF(%)Max.
ESR值(mΩ)Max. 100kHz
星日规格代码Xingri
Part number
XRCA49227*004VT0040
XRCA49227*004VT0050
XRCA49227*004DT0040
XRCA49227*004DT0050
XRCA49337*004VT0040
XRCA49337*004VT0050
XRCA49337*004DT0040
XRCA49337*004DT0050
XRCA49477*004DT0040
XRCA49477*004DT0050
纹波电流 RMS Current100kHz (A)
4 V 85℃下使用 4Volt rating at +85℃
表4 CA49系列电性能 Table4 Electrical characteristics
+25℃ +85℃ +105℃
额定电压Rated
voltageU (V)R
电容量Capacitance C (μF)R
壳号Case size
漏电流DCL(μA)
Max.
损耗DF(%)Max.
ESR值(mΩ)Max. 100kHz
星日规格代码Xingri
Part number
纹波电流 RMS Current100kHz (A)
表4 CA49系列电性能 Table4 Electrical characteristics
6.3 V 85℃下使用 6.3Volt rating at +85℃
6.3
6.3
6.3
6.3
6.3
6.3
6.3
6.3
6.3
6.3
6.3
6.3
6.3
47
68
100
150
150
150
150
220
220
220
220
330
330
B
B
B
V
V
D
D
V
V
D
D
D
D
30
43
63
95
95
95
95
139
139
139
139
208
208
70
70
70
40
50
40
50
40
50
40
50
40
50
1.1
1.1
1.1
1.8
1.6
1.9
1.7
1.8
1.6
1.9
1.7
1.9
1.7
1.0
1.0
1.0
1.6
1.4
1.7
1.6
1.6
1.4
1.7
1.6
1.7
1.6
0.7
0.7
0.7
1.1
1.0
1.3
1.1
1.1
1.0
1.3
1.1
1.3
1.1
10 V 85℃下使用 10Volt rating at +85℃
CA49型聚合物电解质片式钽电容器CA49 series Polymer Solid Electrolyte Tantalum Chip Capacitor
R
※ 所有技术数据在25 下测量。All technical data relates to an ambient temperature at +25 .0 0 ※ 电容量和损耗测试条件Capacitance and DF measured at:U =2.2 V,U =1.0 V RMS(有效值 );测量频率 frequency:120Hz。- ~
※ 漏电流应在施加额定电压5分钟后测量,+105℃时应施加降额电压。DCL is measured at rated voltage after 5 minutes, and derating is applied at +105℃ ※ *代表容量偏差±10%,替换成M代表容量偏差±20%。 refer to tolerance M:±20%。#代表包装方式 # refer to packing T:7" reel,S:13" reel。
℃ ℃-0.5 -1.0
33
8
8
8
10
10
10
10
10
10
10
10
10
10
XRCA49476*006BT0070
XRCA49686*006BT0070
XRCA49107*006BT0070
XRCA49157*006VT0040
XRCA49157*006VT0050
XRCA49157*006DT0040
XRCA49157*006DT0050
XRCA49227*006VT0040
XRCA49227*006VT0050
XRCA49227*006DT0040
XRCA49227*006DT0050
XRCA49337*006DT0040
XRCA49337*006DT0050
22
33
47
68
68
100
100
100
100
150
150
150
150
220
220
330
330
10
10
10
10
10
10
10
10
10
10
10
10
10
10
10
10
10
B
B
B
V
V
V
V
D
D
V
V
D
D
D
D
D
D
8
8
8
10
10
10
10
10
10
10
10
10
10
10
10
10
10
70
70
70
40
50
40
50
40
50
40
50
40
50
40
50
40
50
1.1
1.1
1.1
1.8
1.6
1.8
1.6
1.9
1.7
1.8
1.6
1.9
1.7
1.9
1.7
1.9
1.7
1.0
1.0
1.0
1.6
1.4
1.6
1.4
1.7
1.6
1.6
1.4
1.7
1.6
1.7
1.6
1.7
1.6
0.7
0.7
0.7
1.1
1.0
1.1
1.0
1.3
1.1
1.1
1.0
1.3
1.1
1.3
1.1
1.3
1.1
XRCA49226*010BT0070
XRCA49336*010BT0070
XRCA49476*010BT0070
XRCA49686*010VT0040
XRCA49686*010VT0050
XRCA49107*010VT0040
XRCA49107*010VT0050
XRCA49107*010DT0040
XRCA49107*010DT0050
XRCA49157*010VT0040
XRCA49157*010VT0050
XRCA49157*010DT0040
XRCA49157*010DT0050
XRCA49227*010DT0040
XRCA49227*010DT0050
XRCA49337*010DT0040
XRCA49337*010DT0050
22
33
47
68
68
100
100
100
100
150
150
150
150
220
220
330
330
10
22
33
33
47
47
47
47
68
68
68
68
100
100
150
150
16V 85℃下使用 16Volt rating at +85℃
B
B
V
V
V
V
D
D
V
V
D
D
D
D
D
D
16
35
53
53
75
75
75
75
108
108
108
108
160
160
240
240
8
8
10
10
10
10
10
10
10
10
10
10
10
10
10
10
70
70
40
50
40
50
40
50
40
50
40
50
40
50
40
50
1.1
1.1
1.8
1.6
1.8
1.6
1.9
1.7
1.8
1.6
1.9
1.7
1.9
1.7
1.9
1.7
1.0
1.0
1.6
1.4
1.6
1.4
1.7
1.6
1.6
1.4
1.7
1.6
1.7
1.6
1.7
1.6
0.7
0.7
1.1
1.0
1.1
1.0
1.3
1.1
1.1
1.0
1.3
1.1
1.3
1.1
1.3
1.1
XRCA49106*016BT0070
XRCA49226*016BT0070
XRCA49336*016VT0040
XRCA49336*016VT0050
XRCA49476*016VT0040
XRCA49476*016VT0050
XRCA49476*016DT0040
XRCA49476*016DT0050
XRCA49686*016VT0040
XRCA49686*016VT0050
XRCA49686*016DT0040
XRCA49686*016DT0050
XRCA49107*016DT0040
XRCA49107*016DT0050
XRCA49157*016DT0040
XRCA49157*016DT0050
16
16
16
16
16
16
16
16
16
16
16
16
16
16
16
16
1.5+0.1
4.0±0.1
2.0±0.1
F
E
W
A
C
卷盘尺寸图Reel dimensions and drawing
单位 : mmUnit
壳 号Case size
A±0.2 B±0.2 C±0.1 E±0.1 F±0.1 W±0.3
B 3.1 3.8 4.0 1.75 3.5 8.0
壳 号Case size W
每盘编带只数Qty.per reel
D 12.4 +2.00 / -0.00 7" , "500 13 2500
标识说明
Capacitor markings
B、D、V壳号采用直标法。
Direct designation is used for B、D、V case size.
电容量代码 Capacitance code
容量( F)Capacitance
μ
容量代码Capacitance code
1
A
1.5
E
2.2
J
3.3
N
4.7
S
6.8
W
乘数值Multiplier
第二位数Second digit
410
4
510
5
610
6
710
7
2.0±0.5
178
±2.0
50M
in13
±0.5
W
2.0
2.1+0.5
载带Carrier Tape
盖带Cover Tape
载带运行方向Tape RunningDirection
CA49型聚合物电解质片式钽电容器CA49 Series Polymer Solid Electrolyte Tantalum Chip Capacitor
剥离强度测试 The tension of removing cover tape
拉伸力范围 The tension range: F= 30±15g
B、 D 、V壳(B、D、 V Size)
额定电压Rated voltage
正极色标(+)Polarity Indicator
电容量Capacitance
“星日”标识Xingri logo
107
10V
标识示例
Example of markings
载带尺寸 Tape dimensions
单位Unit: mm
编带包装规范
载带图 Tape drawing
Taping specification
R
O p聚合物类别Polymer typeD 4.7 7.6 8.0 1.75 5.5 12.0
V 4.7 7.6 8.0 1.75 5.5 12.0
B 8.4 +1.5 / -0.00 7" 20 , " 9000 13 00
V 12.4 +2.00 / -0.00 7" 10 , " 4000 13 00
34
贴片
型聚
合物
固体
电解
质钽
电容
器
Hangzhou
●
●Shenzhen Sale Office
●
Dawukou Plant
Add:No.107 Yejin Road, Dawukou District, Shizuishan, Ningxia 753000
Tel:86- 0952-2099013
Fax:86-0952-2099014
Add: 29C Area, B Block,Shennan Garden,No. 11 Kexing Road,
High-Tech Park, Nanshan District, Shenzhen,
Guangdong Province 518057
Tel:0755-26554510
Fax:0755-26553013
Add:
weiye Road,Bingjiang District,Hangzhou,Zhejiang
Tel:13469521880
Sale Office
303 room,1 unit,13Buiding,The silver ocean Apartments,NO.481
310000
Ningxia Xingri Electronics Sale Offices
top related