philips pet830 pet835

DVD Portable Player PET830/PET835

All version

3141 785 31575

Version 1.5

TABLE OF CONTENTS Chapter Technical Specification & Service Tips.... 1 Safety Instructions.. 2 Instruction for Use 3 Mechanical Instructions. 4 Troubleshooting 5 Overall Block Diagram. 6 Electrical Diagram 7 Exploded View Diagram & Service Part List. 8 Revision List. 9

Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips

Service Manual

1.0 TECHNICAL SPECIFICATION

General Dimensions (W x H x D): 255 x 170 x 31 mm Weight: 0.97kg Power supply: 100 240V (AC adaptor)

DC 12V (Battery) Power consumption: 24W Operating temp. & RH: 0 45 degC / 30 90% RH Audio System Output voltage 1kHz: 1.2Vrms typical THD 20-20kHz (%): 0.03% typical Dynamic range: >80dB Signal/Noise ratio: >80dB Frequency response (20-20kHz):

+1dB/-0.5

Channel Separation 1kHz >=85dB Channel Balance 1kHz 1dB Current consumption

DC-IN SUPPLY (9V) Standby Power off 5mA

BATT. SUPPLY Voltage 7.4V Capacity 2600mAH Battery playtime 3 hour Charging time 55dB

Left-Right Channel Balance:

4 -> 0 -> 0 by remote control 4. The screen is under FSM MENU 5. Press to select VERSION,

REGION, AGING and FUNCTION

6. Refer below table for your region code setting

7. Press to save your setting 8. Press SETUP to exit


Procedure on how to upgrade the software of the DVD Portable For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available. A) PANEL firmware upgrade 1. Unzip the WDR830.ROM 2. Drag-n-drop to USB drive 3. Power on PET830 with AC/DC adaptor 4. Insert USB drive to the USB port of the main set 5. The set will detect the updated firmware 6. Press OK to confirm and proceed Warning: Do not unplug the AC adaptor during firmware upgrade to prevent flash corrupt of the set!! B) DVD firmware upgrade 7. Unzip the WDR830.ROM (different file from step 1) 8. Drag-n-drop to USB drive 9. Power on PET830 with AC/DC adaptor 10. Insert USB drive to the USB port of the main set 11. The set will detect the updated firmware 12. Press OK to confirm and proceed Warning: Do not unplug the AC adaptor during firmware upgrade to prevent flash corrupt of the set!!


Symptom:

Pop up screen "FSM AGING FAIL INFO" after replacing the mainboard

Cure:

After replacing the mainboard or LCD, power on the set with below error message:

It could be resolved by the following procedure:

1. Press "SETUP" key on the remote control 2. Press "RETURN" key on the remote control to enter the FSM meun 3. Go to aging with the "NAVIGATION" key on the set ("PLAY/PAUSE" key) 4. Change FSM aging to "FINAL" and then press "OK" key to confirm phase changed 5. Exit the menu by pressing the "SETUP" key

(It could be found by S/C # PI-07/031 on service support site.)

2.0 SAFTETY INSTRUCTIONS

GB WARNING

All ICs and many other semi-conductors aresusceptible to electrostatic discharges (ESD).Careless handling during repair can reduce lifedrastically.When repairing, make sure that you areconnected with the same potential as the massof the set via a wrist wrap with resistance.Keep components and tools also at thispotential.

F ATTENTION

Tous les IC et beaucoup dautressemi-conducteurs sont sensibles auxdcharges statiques (ESD).Leur longvit pourrait tre considrablementcourte par le fait quaucune prcaution nestprise leur manipulation.Lors de rparations, sassurer de bien tre reliau mme potentiel que la masse de lappareil etenfiler le bracelet serti dune rsistance descurit.Veiller ce que les composants ainsi que lesoutils que lon utilise soient galement cepotentiel.

ESD

D WARNUNG

Alle ICs und viele andere Halbleiter sindempfindlich gegenber elektrostatischenEntladungen (ESD).Unsorgfltige Behandlung im Reparaturfall kandie Lebensdauer drastisch reduzieren.Veranlassen Sie, dass Sie im Reparaturfall berein Pulsarmband mit Widerstand verbundensind mit dem gleichen Potential wie die Massedes Gertes.Bauteile und Hilfsmittel auch auf dieses gleichePotential halten.

NL WAARSCHUWING

Alle ICs en vele andere halfgeleiders zijngevoelig voor electrostatische ontladingen(ESD).Onzorgvuldig behandelen tijdens reparatie kande levensduur drastisch doen verminderen.Zorg ervoor dat u tijdens reparatie via eenpolsband met weerstand verbonden bent methetzelfde potentiaal als de massa van hetapparaat.Houd componenten en hulpmiddelen ook opditzelfde potentiaal.

I AVVERTIMENTO

Tutti IC e parecchi semi-conduttori sonosensibili alle scariche statiche (ESD).La loro longevit potrebbe essere fortementeridatta in caso di non osservazione della pigrande cauzione alla loro manipolazione.Durante le riparazioni occorre quindi esserecollegato allo stesso potenziale che quello dellamassa dellapparecchio tramite un braccialettoa resistenza.Assicurarsi che i componenti e anche gli utensilicon quali si lavora siano anche a questopotenziale.

Pour votre scurit, ces documentsdoivent tre utiliss par des spcia-listes agrs, seuls habilits rparervotre appareil en panne.

GBSafety regulations require that the set be restored to its originalcondition and that parts which are identical with those specified,be used.

NLVeiligheidsbepalingen vereisen, dat het apparaat bij reparatie inzijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen,identiek aan de gespecificeerde, worden toegepast.

FLes normes de scurit exigent que lappareil soit remis ltatdorigine et que soient utiliss les pices de rechange identiques celles spcifies.

DBei jeder Reparatur sind die geltenden Sicherheitsvorschriften zubeachten. Der Original zustand des Gerts darf nicht verndert werden;fr Reparaturen sind Original-Ersatzteile zu verwenden.

I Le norme di sicurezza esigono che lapparecchio venga rimessonelle condizioni originali e che siano utilizzati i pezzi di ricambioidentici a quelli specificati.

"After servicing and before returning set to customer perform aleakage current measurement test from all exposed metal parts toearth ground to assure no shock hazard exist. The leakage currentmust not exceed 0.5mA."

CLASS 1LASER PRODUCT

3122 110 03420

GB Warning !Invisible laser radiation when open.Avoid direct exposure to beam.

S Varning !Osynlig laserstrlning nr apparaten r ppnad och sprrenr urkopplad. Betrakta ej strlen.

SF Varoitus !Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiinankymttmlle laseristeilylle. l katso steeseen!

DK Advarse !

Usynlig laserstrling ved bning nr sikkerhedsafbrydere erude af funktion. Undg udsaettelse for strling.

Whenthepowersupplyisbeingturnedon,youmaynotremovethislasercautionslabel.Ifitremoves,radiationoflaser

maybereceived.

2.1 ESD PROTECTION

PREPARATIONOFSERVICING

PickupHeadconsistsofalaserdiodethatisverysusceptibletoexternalstaticelectrocity.

Althoughitoperatesproperlyafterreplacement,ifitwassubjecttoelectrostaticdischargeduringreplacement,

itslifemightbeshortened.Whenreplacing,useaconductivemat,solderingironwithgroundwire,etc.to

protectthelaserdiodeformdamagebystaticelectricity.

Andalso,theLSIandICaresameasabove.

Solderingironwithgroundwireorceramictype

Groundconductivewriststrapforbody.

ConductivematThegroundresistancebetweenthegroundlineandthegroundislessthan10

1M

SAFTY NOTICE

Plug the AC line cord directly into a 120V AC outlet (donot use an isolation transformer for this check). Use anAC voltmeter, having 5000 per volt or more sensitivity.Connect a 1500 10W resistor,paralleled by a 0.15uF150V AC capacitor between a knomn good earth ground(water pipe, conduit, etc.) and all exposed metal parts ofcabinet (antennas, handle bracket, metal cabinetscrewheads, metal overlays, control shafts, etc.).

SAFTY PRECAUTIONS

LEAKAGE CURRENT CHECK

Measure the AC voltage across the 1500 resistor.The test must be conducted with the AC switch on andthen repeated with the AC switch off. The AC voltageindicated by the meter may not exceed 0.3V.A readingexceeding 0.3V indicates that a dangerous potentialexists, the fault must be located and corrected.Repeat the above test with the DVD VIDEO PLAYERpower plug reversed.NEVER RETURN A DVD VIDEO PLAYER TO THECUSTOMER WITHOUT TAKING NECESSARYCORRECTIVE ACTION.

READING SHOULD NOT EXCEED 0.3V

DVD VIDEO PLAYER

AC OUTLET

AC VOLTMETER

Test all exposed metal.Voltmeter Hook-up for Leakage Current Check

0.15uF 150V AC

150010W

(5000 per voltor more sensitivity)

Good earth groundsuch as a water pipe,conduit, etc.

The lightning flash with arrowhead symbol, within anequilateral triangle, is intended to alert the user to thepresence of uninsulated "dangerous voltage" within theproduct's enclosure that may be of sufficient magnitude toconstitute a risk of electric shock to persons.

The exclamation point within an equilateral triangle isintended to alert the user to the presence of importantoperating and maintenance (servicing) instructions in theliterature accompanying the appliance.

3.0 INSTRUCTION FOR USE

PET830

3.0 INSTRUCTION FOR USE

PET835

4.0 MECHANICAL INSTRUCTION

Disassembly Procedure on PET830 Spare Parts

1 Remove five screws on back cabinet to separate top cabinet and back cabinet.

(5pcs)

2 Generally open the front cabinet.

3 Disassemble FPC from turn board on top cabinet.

4 Disassemble connecter of speaker from main board.


5 After 3 and 4 procedures, we will get top cabinet assembly and back cabinet assembly.

6 Remove three conductive fabrics.

(3pcs)

7 Disassemble FPC of TFT-LCD from turn board.


8 Remove six screws on

turn board and jogging board. Disassemble connecter of TFT-LCD from turn board.

(6pcs)

9 Remove two screws on eject board.

(2pcs)

10 Remove all PCB boards on top cabinet. Remove six screws on speaker, and then remove speaker.

(6pcs)


11 Remove six screws and

sponges on TFT-LCD. (6pcs)

(6pcs)

12 Remove TFT-LCD and disassembly of top cabinet is ok.

13 Remove four screws on driver and FFC of driver from main board.

(4pcs)

14 Remove top keypad board from back cabinet, and disassemble FFC from main board.


15 Remove four screws on main board.

(4pcs)

16 Remove six screws on plate metal EMI.

(6pcs)

17 Remove two screws on PCB of battery.

(2pcs)

18 Use tool to remove battery from back cabinet.


19 Finally, we will get the back cabinet.

5.0 TROUBLESHOOTING

SYMPTOM: BATTERY NO POWER

Start

Check Battery capacity?

BATTERY CANT Power ON

Check charging function OK? SET OK?

No Defect, return set to Customer

Check adaptor power-ON OK?no

Check the Power-ON button and cable OK?

Replace Main BoardReplace Button or Cable

yes

Yes

NO

No

Yes

Yes

No

5.0 TROUBLESHOOTING

SYMPTOM: NO IMAGE / NO SOUND

SYMPTOM: NO IMAGE OUTPUT ( THE PANEL SHOW BLUE PICTURE)

Start

Check the external AV Cable TYPEnote and connection is OK?

Replace DVD DriveCheck DVD Drive work?

Replace Main Board

Exchange AV cableNOTE: AV Cable TYPE from outside to Inside L-Audio, R-Audio, Video, Ground

no

yes

no

yes

SYMPTOM: NO SOUND COMES FROM SPEAKER

Start

Check the Connection OK? Reinsertion

Check speaker OK?

Replace Main Board

Change the speaker

no

yes

no

yes

5.0 TROUBLESHOOTING

SYMPTOM: THE DVD DRIVE DOES NOT WORK

SYMPTOM: THE DVD DRIVE DOESNT WORK

Start

Replace DVD-Loader

Check the DVD-Loader OK?

Replace main board

NO

Yes

Yes

Cable ReinsertionNOCheck DVD-Loader connection OK?

5.0 TROUBLESHOOTING

SYMPTOM: ADAPTOR CANNOT POWER ON

Start

Check Adaptor OK?

Adaptor can not Power ON

Change adaptor SET OK?

Return set to Customer

NO

Check the Power-ON button and cable OK? Replace Main Board

Replace Button or Cable

Yes

NO

Yes

No

YES

OK

5.0 TROUBLESHOOTING

SYMPTOM: REMOTE CONTROL CANNOT WORK

SYMPTOM: THE REMOTE CONTROL CAN NOT WORK

Start

Check TOP-board OK?

Replace main board

Yes

Yes

Cable ReinsertionNOCheck CABLE form

bottom board to top board connection OK?

Replace IR receiver

Return to custormer

OK

OK

Replace top boardNONO

OK

5.0 TROUBLESHOOTING

SYMPTOM: USB CANNOT WORK

SYMPTOM: THE USB DOESNT WORK

Start

Add external adaptor on USBOr

Change another USB

Check the external USB power consumption ?

Replace main board

Over spec

Yes

Yes

USB ReinsertionNOCheck USB INSERTION OK?

PET830 USB current limit Is 500mA

SYMPTOM: NO SOUND FROM HEADPHONE

5.0 TROUBLESHOOTING

SYMPTOM: LED DISPLAY FAILURE

SYMPTOM: LED Display Fail

Start

Check TOP-board OK?

Replace main board

NO

Yes

Yes

Cable ReinsertionNOCheck CABLE form Main board to top board connection OK?

Replace LED

Return to custormerOK

Replace top boardNO

OK

OK

5.0 TROUBLESHOOTING

SYMPTOM: KEY & BOTTON FAILURE

SYMPTOM: Key & Botton Fail

Start

Check KEY board OK?

Replace main board

NO

Yes

Yes

Cable ReinsertionNOCheck CABLE form board to board connection OK?

Return to custormerOK

Replace KEY board

OK

5.0 TROUBLESHOOTING

SYMPTOM: DVB-T FAILURE

6.0 OVERALL BLOCK DIAGRAM

PET830 Block Diagram

6.0 OVERALL BLOCK DIAGRAM

55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

Adapter+12V2A

INTERNAL BAT +6.8V~+8.3V2200mAH

BUCKMPS3407+5V_SYS

AUDIO AMPTPA6011A4

+5V_AUD

74HCXXX

ES8380+1.45V

BUCKMPS2109

2nd BAT +6.8V~+8.3V4400mAH

+5V_M

Audio LPFAPC4558

MOTOR DRIVEBH5510

+5V_TUNER

+3.3V_A+3.3V_V+3.3V_D+3.3V_PLL

+5V_RF

SDRAM+3.3V_SD

+3.3V_RF

+3.3V_FLASH

+3.3V_TUNER

ES8380

OPU

Flash ROM

DVB-T NIM MODULELDO(Optional)G961-25ADJTEUf

+1.8V(OPTIONAL)

WDR830 SYSTEM BOARD 02Power Diagram

B

1 28Tuesday, February 06, 2007

Title

Size Document Number Rev

Date: Sheet of

7.0 ELECTRICAL DIAGRAM

55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

RST

DVDProcessorES8380??

24C044KBitsEEPROM

I2C

74HC08D

Host USB( 1.1 )I/O EXTENDER 74HC374

128Mbits-6SDRAM

16MbitsFlash ROM

LD[0..7]

LCD BOARD CON

+8.4V Battery(embeded)

+12VAdapter

Main Board

Power System

Audio DACCS4334(OPTIONAL)

A/V IN

Audio AMPTPA6011A4

Motor DriverBH5510KV

TDR086L CONPUH

HP2 OUT

A/V OUT

HP1 OUT

NIM CON

VIDEO

AUDIO

L/R-LINE OUT

AUDIO-HP2

AUDIO-HP1

AUDIO-VOLUME

L/R

COM9003ASTY

DVB-T NIM Module+8.4V 2nd Battery(Optional)

LCS1#

LPFAPC4558

I2C

CAMCLK

COAXIAL

I2S

SPEAKER

Y/C

CVBS

+5V+3.3V&+1.45V

WDR830 SYSTEM BOARD 02Block Diagram

A3


Title


Date: Sheet of


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

A/V INPUT

A/V OUTPUT

HP1 OUT

HP2 OUT

COAXIAL

ISOLATOR

ISOLATOR

WDR830 SYSTEM BOARD 02AV PORT

A3


Title


Date: Sheet of

AVIN-L

AVIN-CVBS

AVIN-DET_GNDAVIN-DET

AVIN-R

HPGND

AVOUT-CVBS

AVOUT-L

HPROUT

AVOUT-DET_GND

HP2-DET

AVJACKGND

AVOUT-DET

HP1-DETHPLOUT

HPGND

AVOUT-R

AV

JAC

KG

ND

AV

JAC

KG

ND

AVIN_LIN (13)

AVINDET-AUX5 (9)

AVIN_CVBS (21)AVIN_RIN (13)

HP2_DET (13)

HP_L_OUT (13)

AVOUT_R (14)AVOUT_CVBS (26)

AVOUT_L (14)

AVOUT_DET (9)

COAX (14)

HP1_DET (13)

HP_R_OUT (13)

GND_SIGNAL

GND_DC

GND_DC

GND_DC

GND_SIGNALGND_SIGNAL

GND_SIGNAL

GND_SIGNAL

GND_SIGNAL

GND_SIGNAL

GND_SIGNALNET

GND_DC

FB12 1A/600OHM/0603

TBD10NC

J4PJ-328 3

5421

C22510P/50V/0402

FB53 1A/600OHM/0603

FB10 1A/600OHM/0603

TP331

TBD11BCF-35320A

FB13 1A/600OHM/0603

C5010P/50V/0402

R407 1K/F/0603

C5310P/50V/0402

C22210P/50V/0402

R447 75/F/0603

TP11

G

L

RV

J6PJ-362

12

3

45

67

TP1841

G

L

RV

J7PJ-362

12

3

45

67

C37710P/50V/0402

C110P/50V/0402

C91100P/50V/0603

TP1851

C22010P/50V/0402

J2PJ-328 3

5421

TP21

R4770/J/0603

FB71A/600OHM/0603

C610P/50V/0402

FB201A/600OHM/0603

FB8 1A/600OHM/0603

FB1 1A/600OHM/0603

FB11 1A/600OHM/0603

C2010P/50V/0402

C4210P/50V/0402

FB14 1A/600OHM/0603

TP201

C271100P/50V/0603

C1110P/50V/0402

C20910P/50V/0402

J10PJ-328 3

5421

TBD14BCF-35320A

R448 75/F/0603

R471 22/F/0603

FB9 1A/600OHM/0603

C3810P/50V/0402

C5810P/50V/0402

FB3 1A/600OHM/0603

TP91

TBD13NC

C4610P/50V/0402

C19410P/50V/0402

C18710P/50V/0402

C37810P/50V/0402

R4780/J/0603

C21010P/50V/0402

P41

C22610P/50V/0402

C18310P/50V/0402

FB4 1A/600OHM/0603

R64NC

R472 22/F/0603

C18410P/50V/0402

C20710P/50V/0402

R71 1K/F/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

TopRay + QSI TDR086L SLOT-IN Loader

PIN 1

PIN 57

TOP VIEW(DOWNCONTACT)

3

12mil

ISOLATOR

WDR830 SYSTEM BOARD 02Connector of Loader

A3


Title


Date: Sheet of

DVDLD

TRACK+

V5_RF

C

CDLD

HV-

SLED+

PVC

VHVCC

D

TRACK-

CD_DVD

VH

HW+

VR_CD

RF

HU+

FOCUS+

VR_DVD

HW-

F

HU-

FOCUS-

LOAD-

SLED-

B

E

HV+

A

R_MDI

U

V

LOAD+

W

OUT_SW

CDMDI

DVDMDI

HW+

FOCUS+

F

V

D

PVC

FOCUS+

RF

R_MDI

HU-

CD_DVDCT

HV-

CDMDI

OUT_SW

VHVCC

SVREF

HW+

RF

F

HV+

DVDLD

SLED-

RF

HV-

CD_DVDCT

C

HU+

VR_CD

E

CLOSE

CDLD

W

CD_DVD

HU+

SLED-

HU-

HW-

HV+

A

VH

V33CDRF

TRACK+

W

SW2

SLED+

SLED+

HW-

DVDLDO

FOCUS-

B

D

E

U

B

U

CD_DVD

V

SW1

CDLDO

VR_DVD

FOCUS-

VR_DVD

PVC

TRACK+

VH

SW3

C

TRACK-

V5_RF

DVDMDI

TRACK-

SW4

A

VR_CD

SW1

DVDLD

SW4

LOAD+

SW3

OUT_SW

SW2

LOAD-

CDLD

V33DVDRF

LOAD+LOAD-

SW2SW1

SW3SW4

HU- (7)

SVREF (7,9)

PVC (9)

DVDLDO (9)

DVDLDO (9)

FOCUS+ (7)

RF (9)F (9)E (9)

HW- (7)

DVDMDI (9)CDMDI (9)

SW4 (9)SW3 (9)

HV+ (7)

FOCUS- (7)

HU+ (7)

OUT_SW (9)

SW1 (9)

C (9)

TRACK+ (7)

CD_DVDCT (9)

W (7)

VH (7)

V (7)

CLOSE (7,9)

SW2 (9)

B (9)

D (9)

CDLDO (9)

A (9)

TRACK- (7)

SLED- (7)

U (7)

HW+ (7)

SLED+ (7)

HV- (7)

RF (9)

CDLDO (9)

LOAD+ (7)LOAD- (7)

+5V_M

+5V_SYS

+5V_RF

+5V_RF

+3.3V_SYS

+3.3V_SYS

GNDM

GNDM

GND_RF

GND_RF

GND_RF

GND_RF

GND_RF

GND_RF

GND_RFGND_RF

GNDM

GND_RF

GND_POWER

R1453.3/F/0603

FB67 1A/600OHM/0603

TP711

C411 10P/50V/0402

R274100K/F/0402

TP571

TP671

R1261/F/0603

C950.1U/25V/0603

C680.1U/25V/0603

FB181A/600OHM/0603

TP611

TP581

R105560/F/0603

L410UH/50mA/0603

TP791

R2760/J/0402

R262220/J/0603

FB68 1A/600OHM/0603

TP681

TP701

L210UH/50mA/0603

Q142SB1132

B

EC

TP801

Q32PMBS3904

B

EC

TP591

C64 0.1U/25V/0603

R136680/F/0603

TP621

TP841

TP721

Q332SK3018

D

G

S

TP751

L110UH/50mA/0603

TP601

C408 10P/50V/0402

TC5100U/6.3V/B

12

L310UH/50mA/0603

TP921

TC8100U/6.3V/B

12

R96 0/J/0603

TP761

TP1131

TP541

R27710K/F/0402

TP901

TP851

TP741

R2580/J/0603

TP1021

J857P/0.5/DOWN/FPC

123456789101112131415161718192021222324252627282930313233343536373839404142434445464748495051525354555657

G1

G2

A3A3A2A2A1A1

VHVCCH3-H3+H2-H2+H1-H1+VH

OUT_SWTV+TV-

LEDGNDGND

EJECT_SWNC

MTR+MTR+

NCMTR-MTR-FO+TR-TR+FO-NC

LD(DVD)GND

LD(CD)MD

VR(DVD)VR(CD)

GNDVREFVCC

NCEF

RFSWNC

ABCD

NCNC

SW1SW2SW3SW458

59

TP811

TP531

TP931

TP941

TP771TP781

R2750/J/0402

TP1141

R27210K/F/0402

TP511

FB69 1A/600OHM/0603

Q34PMBS3904

B

EC

C901N/25V/0603

TP521

TP861

Q312SK3018

D

G

S

R27310K/F/0402

C409 10P/50V/0402

C721N/25V/0603

TP641

TP551

TP891

C870.1U/25V/0603

TP881

R10410K/F/0603

Q182SB1132

B

EC

FB70 1A/600OHM/0603

TP661

C930.1U/25V/0603

R13510K/F/0603

C410 10P/50V/0402

C850.1U/25V/0603

TC1547U/10V/B

12

TP631

TP691

TP561


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

ISOLATOR

WDR830 SYSTEM BOARD 02CON_USB

A


Title


Date: Sheet of

D+_USBD-_USB USB_N0

USB_P0

5V_USB

USB_N0 (9)USB_P0 (9)

+5V_SYS

GND_DC

GND_DC GND_POWER

GND_POWER GND_POWER

R10115K/F/0603

R100 33/J/0603

C242

EG

A10603V

05A1 5V

C610.1U/25V/0603

J9USB-A

1234

G1

G2

VCCD-D+

GND

G1

G2

FB151A/600OHM/0805

TC247U/10V/B

12

R9515K/F/0603

C600.1U/25V/0603

TP731

C6510P/50V/0603

TP83

1CK1L0114S0133DLW31S

12

3 4

C6310P/50V/0603

F51206L075

C241

EG

A10603V

05A1 5V

P71

R97 33/J/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

L:ActiveH:OFF

ISOLATOR

5.12MHz7xx~1.9MHz

WDR830 SYSTEM BOARD 02CON OF NIM Module

A


Title


Date: Sheet of

VT_M

TUNER_STR

TUNER_NC

IF-OUT_M

TUNER_RST

TUNER_FAIL

TUNER_SDA

TUNER_SCL

TUNER_D0

TUNER_D1

TUNER_D2

TUNER_D3

TUNER_D4

TUNER_D5

TUNER_D6

TUNER_CAMCLK

FLAG0

FLAG3

FLAG7

FLAG6

FLAG4

FLAG2

FLAG1

FLAG5

FLAG[0..7]

TUNER_D7

SDA (8,9,21)

SCL (8,9,21)

PWR_TUNER (19)

DVB_RST (19)

CAMCLK (9)

FLAG[0..7] (9)

TP11 1

TP1751

TP28 1

C13 10P/50V/0402

R15 0/J/0402

TP12 1

TP311

C384 10P/50V/0402

TP15 1

C15 10P/50V/0402

TP24 1

R43 0/J/0603

R16 0/J/0402

TP13 1

C12 10P/50V/0402

C383 10P/50V/0402

TP1741

R13 0/J/0402

TP25 1

R6 0/J/0402

C14 10P/50V/0402

TP171

R14 0/J/0402

C18 10P/50V/0402

TP181

TP81

C35 NC

R11 0/J/0402

TP301

C17 10P/50V/0402

R18 0/J/0402

TP221TP211

R12 0/J/0402

C16 10P/50V/0402

J1

24P/0.5/DOWN/FPC

23

24

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

R9 0/J/0402

TP26 1

R468 0/J/0402

TP27 1

R10 0/J/0402

C405 10P/50V/0402

R17 0/J/0402

TP14 1

C19 10P/50V/0402

C385 10P/50V/0402


AA

B

B

C

C

D

D

E

E

4 4

3 3

2 2

1 1

TRAY MOTORCONTROL

WDR830 SYSTEM BOARD 02MOTOR DRIVE


Title


Date: Sheet of

FO+

U10-11

SVREF

U10

-43

U10

-46

HV

+

U10

-44

U10

-42

TRACKING

U10-13

U

U10

-40

TR+

U10

-41

HW

+

W

SLED-

SPINDLE

FOCUS+

HW

-

IN5

U10-12

STBY

SLED+

FOCUS

TRACK+

TRACK-

TR-

U10

-45

HU

+

U10

-38

FG

V

HV-

SLED

U10-14

AMPSTBY

HU

-

U10

-39

INSP

IN5

FOCUS- FO-

U10

-23

VH

W (4)

HV+(4)

FOCUS-(4)

HW-(4)

FOCUS+(4)

HU+(4)

VH(4)

V (4)

TRACK+(4)

SVREF (9)

U (4)

TRACK-(4)

HW+(4)

HV-(4)

HU-(4)

AMPSTBY(9)

TRO(9)

FOO(9)

SLO(9)

DMO(9)

SVREF (9)

CLOSE(9) EJECT_SW (9)

LOAD- (4)

LOAD+ (4)

FG(9)

SLED-(4)

SLED+(4)

+5V_M

+5V_M

+5V_M

+5V_M

+5V_M

+3.3V_SYS

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

GNDM

+3.3V_SYS

GNDM

GNDM

BH5510KV

U6BH5510KV

13

1

2

3

4

5

6

7

8

9

10

11

12

14 15 16 17 18 19 20 21 22 23 24

25

26

27

28

29

30

31

32

33

34

35

36

48 47 46 45 44 43 42 41 40 39 38 37

SP

CN

F

FG

GVSW

BMSW

STBY

VO1F

VO1R

PGND1

VO2F

VO2R

PVCC1

VO3F

VO3R

CPH

GN

D

VCC

HU

P

HU

N

HV

P

HVN

HW

P

HW

N

HB

PVC

C21 RNF1

U

V

PVCC22

RNF2

W

PGND3

VO4F

VO4R

PVCC3

VO5F

VO5R

INS

P

IN5

IN4

IN3

IN2

IN1

CN

F1

CN

F2

CN

F3

CN

F4

CN

F5

VR

EF

R238 150/F/0402

C3860.1U/25V/0603

R42 47K/F/0402

DMO 1

TP471

TC1447U/10V/B

12

R244 NC

R69330/F/0402

C431N/50V/0402

TP39 1

R65 0/J/0603

TP46 1

R243 3.3K/F/0402

R30 NC

R235680/F/0402

R52 0/J/0603

C31 47N/50V/0603

R46 1A/600OHM/0603

R37 5.1K/F/0402

TP35 1

C2120.1U/25V/0603

C30 47N/50V/0603

R2321K/F/0402

TP38 1

C26 0.47U/16V/0603C32 47N/50V/0603

C1981U/16V/0603R332 47K/F/0402

TC1247U/10V/B

12

R67 0/J/0603

R39 4.7K/J/0402

R660.22/F/0603

R50 0/J/0603TP481

C33 33N/50V/0603

C420

1U/25V/0603

C440.01U/50V/0603

C28 0.01U/50V/0603

C27 0.01U/50V/0603

R44 NC

TP40 1

TP36 1

C34 33N/50V/0603

R240 150/F/0402

R48 1A/600OHM/0603

U2

NC7SB3157

6

5

1

2

34

S

VCC

B1

GND

B0A

TRO 1

R40 0/J/0603

R53 0/J/0603

TP41 1

TC1347U/10V/B

12

C2060.1U/25V/0603

R38 12K/F/0402

C2080.1U/25V/0603

R45 56K/F/0402

FOO 1

R242 NC

R2341.2K/F/0402

C2110.1U/25V/0603

C421

1U/25V/0603

R2331K/F/0402

R54 0/J/0603

SLO1

C25 0.47U/16V/0603

TP37 1

R47 22K/F/0402

R360/J/0402


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

I2C ADDR = 0XA0

WDR830 SYSTEM BOARD 02EEPROM

A


Title


Date: Sheet of

EE_SCLEE_SDA

3V3_EE

SCL (6,9,21)SDA (6,9,21)

+3.3V_SYS

R2254.7K/F/0603

R2264.7K/F/0603

R224 0/J/0603

C1850.1U/25V/0603

U2024C04

1234 5

678A0

A1A2GND SDA

SCLWP

VCC

FB221A/600OHM/0603

R227 0/J/0603


AA

B

B

C

C

D

D

E

E

4 4

3 3

2 2

1 1

Tuner Interface

EXT IO

MOTOR

USB

SDRAM

IR

Close IC

TDR086L

GND GUARD

GND GUARD

SPACE=7 MILWIDTH=7mil, 1 VIA

WIDTH=7mil, 1 VIA

SPACE=35 MIL

SPACE=35MILVERY CLOSE 8380

Close IC

Flash ROM

EEPROM

ANALOG

AUDIO

VIDEO

I2S

close ES8380

WDR830 SYSTEM BOARD 02ES8380


Title


Date: Sheet of

FOO

TRO

AMPSTBY

DMO

FG-LCS2

SLO

FLAG7

FLAG0

FLAG5FLAG6

FLAG4

FLAG2

FLAG[0..7]

LCS1

LD[0..7]

REFDPVC

FLAG1

FLAG3

R_FLAG0R_FLAG1R_FLAG2R_FLAG3R_FLAG4R_FLAG5R_FLAG6R_FLAG7

DSS1

SCLSDA

USB_P0USB_N0

DCAS

DQM

DRAS0DCS0

DWE

DB[0..15]

DMA[0..11]

DBANK1

DSCK

DBANK0

SD

AS

W1

TXD

LCS

3

DR

FP

SLO

LA10

BC

FOO

SPNP

S_Y

DB9

R_F

LAG

18380-122

LCS

0

DR

FN

DB10

LA13

R_F

LAG

6

EA

UX

02

LA3

DB8

CDLDO

VREF

F

LOE

XIN

CLOSE

FE

CDAC

EJECT_SW

FE

LA17

S_C

SW3

DB1

LA0

TE

R_F

LAG

7LA15

PI

LA19

LA18

DB15

R_F

LAG

5

DVDMDI

LA16

COMP

DB0

DCKE

LA9

IDAC

VDAC

WR

LL

A

DBANK0DSS1

CD_DVDCT

CD

MD

I

DB11

DB3DB4

LA12

DB2

8380_CVBS

SW4

DRAS0

LA21

DEHPV

CM

IN

DCS0

FDAC

R_F

LAG

2

RE

FD

LA6

GPV

C

AMPSTBY

FG-L

CS

2

DB6

CD

PD

R_F

LAG

3

8380-1248380-123

DVDPD

8380

RS

T

8380-119

DSCK

LA7

LA14

LA5

LA1

TRO

TE

DB7

DWE

DB13

DCAS

SVREF

EA

UX

03

LA2

DB14

LA20

YDAC

PVC

DBANK1

8380-129DB5

LA4

R_F

LAG

4

UDAC

RF

DQM

LCS

1

LA8

CP

UC

LK

DM

O

DVDLDO

RXD

DB12

SPNN

LA11

R_F

LAG

0

A

SW4

DVDMDI

CDLDODVDLDO

CD_DVDCT

F

SW3

D

PVC

SW1

CLOSE

RF

E

C

CDMDI

B

SVREF

LD0

LD1

LD2

LD3

LD4

LD5

LD6

LD7

US

B_P

0U

SB

_N0

SPNP

SPNPEJECT_SW

EAUX03

8380-1178380-118

AUX7

AUX7

MIN

AV

IND

ET-

AU

X5

SVREF

AD

C_B

IAS

SPDIFOUT

SILE

NC

E_D

ET

I2C

_IN

TIR

_IN

XO

UT

XIN

XOUT

DMA6DMA5DMA4

DMA9DMA3

DMA8

DMA11

DMA1

DMA10DMA0

DMA2

DMA7

AVINDET-AUX5

S_Y

SCL

LOE

8380-118

LA[0..21]

8380-124

LCS3

I2C_INT

8380-117

8380_CVBS

SPDIFOUT

SDA

SILENCE_DET

8380RST

S_C

WRLL

LD[0..7]

FG-LCS2

PLL2 DRAS0PLL1 DWEPLL0 DCKE

PLL3 DCAS

TXDRXD

8380-129

AU

X2

SC

L

RSET SLO (7)

FG (7)AMPSTBY (7)

DMO (7)FOO (7)

TRO (7)

FLAG[0..7] (6)

CAMCLK (6)

LCS1 (10,19)

LD[0..7] (10,19)

USB_N0 (5)USB_P0 (5)

DB[0..15] (12)

DWE (12)

DMA[0..11] (12)

DBANK0 (12)

DSCK (12)

DRAS0 (12)

DBANK1 (12)

DQM (12)

DCAS (12)

DCS0 (12)

A (4)

SW1 (4)SW2 (4)

PVC (4)

CDMDI (4)DVDMDI (4)

SW3 (4)

SVREF (7)

OUT_SW (4)

SW4 (4)

CLOSE (7)

EJECT_SW (7)

C (4)

CDLDO (4)

E (4)F (4)

D (4)

RF (4)

B (4)

DVDLDO (4)

CD_DVDCT (4)

AVOUT_DET (3)

IR_IN (21,24)

AU_D0 (14)

WRLL (10)

LA[0..21] (10)

LOE (10)

8380_CVBS (26)

LCS3 (10)

SDA (6,8,21)SCL (6,8,21)

S_Y (21)

8380RST (10,11)

S_C (21)

LD[0..7] (10,19)

SILENCE_DET (13)

AU_BCK (14)

SPDIFOUT (14)

I2C_INT (21)

AU_MCK (14)

AVINDET-AUX5 (3)

AU_LRCK (14)

FG-LCS2 (10)

+3.3V_D

+3.3V_V +3.3V_RF

+3.3V_D

+3.3V_PLL

+1.45V

+3.3V_RF

+3.3

V_R

F

+3.3V_V

+3.3

V_P

LL

+3.3

V_D

+1.45V

+3.3V_D

+1.4

5V

+3.3V_D

+3.3V_D

+3.3

V_D

+3.3V_V

+3.3V_D

+3.3V_D

+1.4

5V

+3.3

V_D

+3.3V_DAC

+3.3

V_D

+3.3V_D

+1.4

5V

+1.45V

+3.3

V_A

VD

+3.3V_D

+3.3

V_D

+3.3

V_D

+3.3V_D

+1.4

5V

+3.3V_D

GND_RF

GND_RF

GND_RF

GND_RF

+3.3V_D

+3.3

V_U

SB

GNDV

GNDV

GNDV

+3.3V_AVD +3.3V_USB +3.3V_DAC

+3.3V_D

+5V_SYS

GND_POWER

+3.3V_D

GND_POWER

TP1111

C234

0.1U/16V

/0402

C244

0.1U/16V

/0402

C237

0.1U/16V

/0402

R98

4.7K/J/0402

C7047N/25V/0603

R102

33/J/0402

C69

680P

/50V

/040

2

TP87

1

RP7 33/J/8P4R/20101234 5

678

R266 33/J/0603

R59

4.7K

/J/0

402

C215

0.1U/16V

/0402

C73 0.1U/25V/0603

R81

33/J/0402

TC2547U/10V/B

12

TP82

1

R114 1K/F/0603

R720.2A/1KOHM/0402

R432 0/J/0603

R83

0/J/

0402

TP1011

R80100K/F/0402

C422

33P/50V/0402

C227

0.1U/16V

/0402

R99

33/J/0402

C80 NC

R128

4.7K/J/0402

C78 4.7N/50V/0402

C216

0.1U/16V

/0402

R25

30.

2A/5

00O

HM

/040

2

C47

0.1U/16V

/0402

R421

0/J/0402

C77 1N/50V/0402

C2360.1U/16V/0402

R251 33/J/0603

R107 1A/600OHM/0603

C413 NC

RP533/J/8P4R/2010

1234 5

678

TP166

C235

0.1U/16V

/0402

C23

90.

1U/1

6V/0

402

R92

33/J/0402

R24

90.

2A/5

00O

HM

/040

2

TP1101

J18

1.0/VA/WAFER4321

GNDTXRX

+5V

RP633/J/8P4R/2010

1234 5

678

R256 4.7K/J/0402

R60

4.7K

/J/0

402

R111 1K/F/0603

C5122P/50V/0603

C238

0.1U/16V

/0402

C71

680P

/50V

/040

2

R25

50.

2A/5

00O

HM

/040

2

R117 4.7K/J/0402

C45

0.1U/16V

/0402

R77

33/J/0402

C62330P/50V/0603

TP991

R2704.7K/J/0603

R259 33/J/0603

TP1091

R121 3.3K/F/0402

C82 1N/50V/0402

R85

33/J/0402

R106 910/F/0603

R116 33/J/0402

C84 22N/25V/0603R118 10K/F/0402

R62

4.7K

/J/0

402

C2400.1U/25V/0603

C247

0.1U/16V

/0402

R110 1K/F/0603

R32968K/J/0603

C231

0.1U/16V

/0402

TP1001

R246 33/J/0603

R10

30/

J/04

02

C250

0.1U/16V

/0402

R79

33/J/0402

R265 100K/J/0603

R127

4.7K/J/0402

TP1761

FE

R26

00.

2A/5

00O

HM

/040

2

FB71 FBMA-11-100505-102T

TP971

R254 33/J/0603

R750/J/0402

R115 1K/F/0603

R73 0/J/0402

C233

0.1U/16V

/0402

C52

0.1U/16V

/0402

TE

R944.7K/J/0603

C232

0.1U/16V

/0402

TP1771

R26

833

/J/0

402

C5922P/50V/0603

R91

0/J/

0402

TP96

V2.2

U8

ES8380

123456789

10111213141516171819202122232425262728293031323334353637383940414243444546474849505152

53 54 55 56 57 58 59 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100

101

102

103

104

105106107108109110111112113114115116117118119120121122123124125126127128129130131132133134135136137138139140141142143144145146147148149150151152153154155156

157

158

159

160

161

162

163

164

165

166

167

168

169

170

171

172

173

174

175

176

177

178

179

180

181

182

183

184

208

207

206

205

204

203

202

201

200

199

198

197

196

195

194

193

192

191

190

189

188

187

186

185

60

VD33DMA7DMA8DMA9DMA3DMA2DMA1DMA0VS33VD33DMA10DMA11DRAS2#DRAS1#/DCS1_BDCS1#/VSYNC/CAM_CLK/TDMDR/RSD/HOMESWDCS0#VDDVSSSEL_PLL2 / DRAS0#SEL_PLL3 / DCAS#SEL_PLL0 / DOE#SEL_PLL1 / DWE#VS33VD33DSCKDQMDB7DB6DB5DB4DB3DB2DB1DB0VS33VD33DB8DB9DB10DB11DB12DB13DB14DB15VS33VD33LA16LA15LA14LA13LA12VS33

VD

33LA

11LA

10LA

9LA

20V

S33

VD

33

LWR

LL#

LA19

LA18

LA8

VS

SV

DD

LA7

LA6

LA5

LA4

LA3

VS

33V

D33

LA2

LA17

LA0

LCS

0# /

GP

IO M

UTE

LCS

1#LC

S2#

/ H

SY

NC

/ FG

IN /

TDM

FS /

RW

SV

DD

VS

SLC

S3#

LD7

LD6

LD5

LD4

LD3

LD2

VS

33V

D33

LD1

LD0

LOE

#LA

1P

AD

_CN

TL /

SP

DIF

_OU

T / E

AU

X03

SP

DIF

_IN

/ E

AU

X02

AV

D33

US

B_P

0U

SB

_N0

AD

C_B

IAS

MIC

_LM

IC_R

AV

S33

VD

33P

LL

VS33PLLVREF

COMPRSETFDACVDAC

VD33DACVS33DAC

YDACCDACUDACIDAC

TWS / PWM_O1L/TXD1TSD0 / PWM_O2LTSD1 / PWM_O2R

VD33VS33

TSD2 / PWM_O3LTSD3 / PWM_O3R / EAUX00TBCK / PWM_O1R / EAUX01

TXD0 / AUX15 / STEP_FDR / LINE_OL / SOUTRXD0 / AUX14 / STEP_RDR / LINE_OR / SIN

VDDVSS

MCLKVD33VS33

AUX7 / RXD1/SOUTLDCO

AMPSTBYCLOSESW

CLOSEOPENSW

OPEN / VOBSVPBVGB

MPDBMBTEFE

V165OPI

REXDVDLD

CDLDVB0

DVDPDAGC2AGC1

SPNN / MNTRNSPNP / MNTRP / IMSR

VP

AV

GA

DR

FND

RFPABCDEFGHMIN

SLV

DM

OFO

OS

LOTR

OC

DP

DR

EFD

AV

D33

AV

S33

DV

CC

VD

33V

S33

FLA

G7

/ AU

X37

/ C

AM

IN7

FLA

G6

/ AU

X36

/ C

AM

IN6

VID

_XI

VS

33D

MA

6D

MA

5D

MA

4A

UX

1R

ES

ET#

AU

X3/

IP2

AU

X0

AU

X2/

IP1

AU

X6

/ ID

SE

L/S

INA

UX

4A

UX

5 / L

GV

DD

VS

SFL

AG

0/G

PI/T

P/A

UX

30/C

AM

IN0/

SD

FLA

G1/

GP

IO/T

P/A

UX

31/C

AM

IN1/

THM

_WFL

AG

2/G

PIO

/TP

/AU

X32

/CA

MIN

2/P

_DW

N_D

RV

FLA

G3

/ GP

IO /

TP /

AU

X33

/ C

AM

IN3

FLA

G4

/ GP

IO /

TP /

AU

X34

/ C

AM

IN4

FLA

G5

/ GP

IO /

TP /

AU

X35

/ C

AM

IN5

VD

33V

S33

CLK

/ TD

MC

LK /

RB

CK

VID

_XO

LA21

R26

30.

2A/5

00O

HM

/040

2

C74 0.1U/25V/0603

R333 330/F/0603

C251

0.1U/16V

/0402

R76

33/J/0402

R271 33/J/0603

TP951

TC2047U/6.3V/A

12

R261 NC

R78

33/J/0402

R129

4.7K/J/0402

C217

0.1U/16V

/0402

TP112

C83 0.15U/25V/0603

R130

4.7K/J/0402

R108 1A/600OHM/0603

TP911

C412 NC

C243

0.1U/16V

/0402

R24

70.

2A/5

00O

HM

/040

2

XT127M/HC-49SMA

R120 6.8K/F/0402

C81 100P/50V/0402

TP1081

R269 33/J/0603

R93

0/J/

0402

C79 NC

C248

0.1U/16V

/0402

C213

0.1U/16V

/0402

R252 100K/J/0603

R248

4.7K/J/0402

C252

0.1U/16V

/0402

R82

33/J/0402

R420 0/J/0603

TC21100U/6.3V/B

12

C218

0.1U/16V

/0402

C249

0.1U/16V

/0402

TP1061

TP1051

R119 0/J/0402

R24

50.

2A/5

00O

HM

/040

2

R109 1A/600OHM/0603

R61

4.7K

/J/0

402

R264 33/J/0603

R469NC

R63 33/J/0402

C214

0.1U/16V

/0402

R280

4.7K/J/0402

FB72 FBMA-11-100505-102T

C2540.1U/16V/0402

TP981


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

WDR830 SYSTEM BOARD 02FLASH ROM

A4


Title


Date: Sheet of

WRLL

LA4

LA7

LA13

LD5

FG-LCS2

FLASH_CS

LD1

LA15

LA3

LA10

LD7

LA6

LCS3

LOE

LA9

LA0

LA17

LA2

LA20

LD3

8380RST

LA18

8380RST

LA16

LD2

LA1

LOE

LA21

LA[0..21]

LA19

WRLL

LA5

LA8

LA12

LD4

LD6

LD[0..7]

LD0

LA14

LA11

FG-LCS2

LCS3

LA5

LD7

LA13LA12

LA21

LA3

8380RST

LA2

LA14

LA20

LA16

LA9

LD4

LA18

LA17

LD5

LA4

WRLL

LD1

LA19

LA11

LD3LD2

LA7

LA10

ROMSEL

LD0

LA15

LA6

LA0

LD6

LA8

LA1LOE

LCS1

LCS1 LCS3 (9)

LOE (9)WRLL (9)8380RST (9,11)

LA[0..21] (9)

FG-LCS2 (9)

LD[0..7] (9,19)

LCS1 (9,19)

+3.3V_FLASH

+3.3V_FLASH

+3.3V_FLASH

GND_POWER

+3.3V_SYS

GND_POWER

+3.3V_SYS

+5V_SYS

R4050/J/0603

R884.7K/J/0603

R900/J/0603

C480.1U/25V/0603

R335NC

R89NC

Z1

36P/0.5/DOWN/FPC

252627282930313233343536

123456789101112131415161718192021222324252627282930313233343536

R470NC

U22

MX29LV160CTTC-70G

123456789

101112131415161718192021222324 25

2627282930313233343536373839404142434445464748A15

A14A13A12A11A10A9A8NCNCWRPVPPDU/WPNCNCA17A7A6A5A4A3A2A1 A0

CEGND

OEDQ0DQ8DQ1DQ9DQ2

DQ10DQ3

DQ11VCCDQ4

DQ12DQ5

DQ13DQ6

DQ14DQ7

DQ15/A_1GND

BYTEA16

R334NC

C660.1U/25V/0603

R267NC

C490.1U/25V/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

WDR830 SYSTEM BOARD 02RESET

A


Title


Date: Sheet of

8380RST(9,10)

MRST (21)

BOTMRST(24)

INTBAT_DISCHG

+3.3V_SYS +5V_SYS

Q452N7002

D

G

S

R492NC

U23G692L263TCUF

2 3

1 4

RST MR

GND VCC R3381K/J/0603

R3364.7K/J/0603

R33710K/J/0603

C3230.1U/25V/0603

C324NC

VC5NC


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

WDR830 SYSTEM BOARD 02SDRAM

A4


Title


Date: Sheet of

BANK0

MMA8

DQM

MB14

MMA6

MB9

DCS0 CS0

MMA11

R_DSCK

MB12

DCAS

MMA9

DBANK1

RAS0

MMA1 MB1

DBANK0

CS0

DCS0

MB13

DRAS0

MB7

CKE

MB2

MMA5

MMA0

MMA7

BANK1

MB5

CAS

MB0

WE

BANK0DBANK0

DWE WE

DMA[0..11]

CKE

MB6

MMA10

MMA4 MB4

DQMX

DCAS CAS

DWE

MMA2

MB8

MB11

MB15

DB[0..15]

DQM DQMX

MB10

MMA3 MB3

DSCK

MMA3DMA3

BANK1DBANK1

RAS0DRAS0

DSCK

MB10

MB1MB0

MB11

MB3

MB8

MB4

MB7

MB13

MB2

MB9

MB12

MB6

MB15MB14

MB5

DB7

DB15

DB12

DB14

DB11

DB1DB0

DB3

DB5DB4

DB6

DB13

DB2

DB9DB10

DB8

DMA0 MMA0

MMA2DMA2

MMA11DMA11

MMA6DMA6DMA5 MMA5

MMA1DMA1

MMA8DMA8

DMA10 MMA10

MMA7DMA7

DMA9 MMA9

DMA4 MMA4

R_DSCK

DWE (9)

DB[0..15] (9)

DSCK (9)

DBANK1 (9)

DMA[0..11] (9)

DQM (9)

DCS0 (9)DRAS0 (9)

DBANK0 (9)

DCAS (9)

+3.3V_SD

+3.3V_SD

+3.3V_SD

C4146.8P/50V/0402

C1920.1U/16V/0402

R474NC

RP4

33/J/8P4R/2010

1234 5

678

C1990.1U/16V/0402

R2304.7K/J/0603

C193NC

RP2

33/J/8P4R/2010

1234 5

678

U3

M12L64164A-6TG

1

24

6

57

3

810

12

1113

9

15

16

17

18

19

3522

23242526

14

28

293031323334

36

37

38

39

40

43

4244

46

4547

49

4850

52

5153

41

2021

27

54

VCC

DQ0DQ1

VSSQ

DQ2DQ3

VCCQ

DQ4DQ5

VSSQ

DQ6DQ7

VCCQ

DQML

WE

CAS

RAS

CS

A11A10

A0A1A2A3

VCC

VSS

A4A5A6A7A8A9

NC

CKE

CLK

DQMH

NC

VCCQ

DQ8DQ9

VSSQ

DQ10DQ11

VCCQ

DQ12DQ13

VSSQ

DQ14DQ15

VSS

BA0BA1

VCC

VSS

R4870/J/0805

C1910.1U/16V/0402

C2030.1U/16V/0402

R23149.9/F/0603

C2000.1U/16V/0402

RP3

33/J/8P4R/2010

1234 5

678

RP1

33/J/8P4R/2010

1234 5

678

C2020.1U/16V/0402

C2010.1U/16V/0402


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

L:MUTEH:ACTIVE

H:MUTEL:ACTIVE

H:MUTEL:ACTIVE

(500ms Fade On)Headphone max volumeHeadphone and speaker difference

Default Output

F/W controlL:MUTEH:ACTIVE

LM312-004-TF1-3

WDR830 SYSTEM BOARD 02AUDIO STEREO AMPLIFER

B


Title


Date: Sheet of

6011HP_ROUT

RLINEIN

SPK_R-

6011HP_LOUT

SYS_MUTE

HP_MUTE

AVIN_SW

LHPIN

SPK_

L+

RHPIN

HP_MUTE

SPK_

R+

LLINEIN

IO_MUTE

HP_MUTE

SYS_MUTE

SPK_R+

SPK_L-SPK_L+SPK_R-

SPK_L-

AVIN_SW (19)

HP1_DET (3)

DAC-RIN(14)

DAC-LIN(14)

HP2_DET (3)

AVIN_LIN(3)

HP_L_OUT (3)

VOLUME (21)AVIN_RIN(3)

HP_R_OUT (3)

SYS_MUTE (14)

IO_MUTE (19)

SILENCE_DET (9)

AVIN_SW(19)

+5V_AUD

+5V_AUD

+5V_AUD

+5V_AUD

+5V_AUD

+5V_AUD

+5V_SYS

+5V_SYS

GND_POWER+5V_SYS

GND_POWER

Q92SD1328

B

EC

SPKR+SPKR-SPKL+SPKL-

J54P/2.0/RA/WAFER

G1

G2

1234

C55 1U/16V/0603

C57 1U/16V/0603

R417

2.2M/F/0402

R86

100K/F/0603

R419 NC

EC1220U/6.3V/SMD63*58

12

C325 1U/16V/0603

R27

1K/J/0603

R418

2.2M/F/0402

+

D2RLS4148N

A K

Q46PMBS3906

CE

B

Q102SD1328

B

EC

R58 100K/F/0603

R3510K/F/0603

Q54PMBS3904

B

EC

C56 1U/16V/0603R450 0/J/0603

TP170

R4910K/F/0603

D8BAV70-F

K

AJ

R294.7K/J/0603

D7MA2J728

A K

R57 100K/F/0603

EC2220U/6.3V/SMD63*58

12

Q4PMBS3904

B

EC

TP169

D6MA2J728

A K

TC18100U/6.3V/B

12

C326 1U/16V/0603

U7TPA6011A4PWPR

65

1234

789

101112 13

1415161718192021222324

25

RINRLINEIN

PGND1ROUT-PVDD1RHPIN

VDDLINLLINEINLHPINPVDD2LOUT- PGND2

LOUT+SHOTDOWN

FADEBYPASS

AGNDSEMAXSEDIFF

VOLUMEHP/ LINE

SE/BTLROUT+

GN

DTP6Reset

R449 0/J/0603

+

D5RLS4148N

AK

R4224.7K/J/0603

TP172

R341K/J/0603

2 1

TC17100U/6.3V/B

12

R55 100K/F/0603

TP171

R451100K/J/0603

C39 1U/16V/0603

R24100/J/0603

R4231K/J/0603

R511K/J/0603

2 1

R231M/F/0603

C2300.1U/25V/0603

C54 1U/16V/0603R56 0/J/0603

+

D25NC

A K

TC1100U/6.3V/B

12

Q53PMBS3904

B

EC

C2290.1U/25V/0603

C5NC

R87

100K/F/0603

C2280.1U/25V/0603

R510K/J/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

L:MUTEH:ACTIVE

H:MUTEL:ACTIVE

H:MUTEL:ACTIVE

WDR830 SYSTEM BOARD 02AUDIO FILTER

A3


Title


Date: Sheet of

OPREF

4334-LOUT

OPVCC-

OPVCC+

OPREF

4334-LOUT

4334-ROUT

4334-ROUT

COAX

SYS_MUTE

OPVCC+

OPVCC-

AU_MCK(9)

COAX (3)

AU_BCK(9)

AVOUT_R (3)

AU_D0(9)

SPDIFOUT(9)

SYS_MUTE(13)

AVOUT_L (3)

AU_LRCK(9)

DAC-LIN (13)

DAC-RIN (13)

+5V_SYS

GND_SIGNAL

+5V_D

GND_SIGNAL

+5V_SYS

+5V_SYS

GND_SIGNAL

GND_SIGNAL

GND_SIGNAL

-5V_SYS

GND_SIGNAL

C419

10U/10V/1206

Q48NC

B

EC

R2911K/F/0603

R13847K/J/0402

2

1

FB571A/600OHM/0603

C89820P/50V/0402

R14056K/F/0402

C881N/50V/0402

1

2

TC3347U/10V/B

12

Q172SD1328

B

EC

R2860/J/0402

U9CS4334-KSZ

1234 5

678SDATA

DEM/SCLKLRCKMCLK AOUTR

AGNDVA

AOUTL

R1244.7K/J/0603

R2841K/F/0603

R3420/J/0402

TC3447U/10V/B

12

R16930K/F/0402

C390NC

C9456P/50V/0402

C2700.1U/25V/0603

R1311K/F/0402

21

R1221K/J/0603

R3400/J/0402

R457 33/F/0603

C2630.1U/25V/0603

FB581A/600OHM/0603

C269NC

R458 33/F/0603

TC747U/10V/B

R4550/J/0402

C388NC

Q152SD1328

B

EC

Q47

PMBS3906

CE

B

R456 33/F/0603

C2592.2N/50V/0603

R13330K/F/0402

R459 33/F/0603

C40710U/16V/1206

+

TC647U/10V/B

R482 10K/J/0603

C118820P/50V/0402

R1421K/F/0402

2 1

R144220/F/0402

2 1

D10 MA2J728A KD9 MA2J728

A K

R125220/F/0402

21

C2782.2N/50V/0603

+

-

U10BUTC 3308L

5

67

84

+

TC1047U/10V/B

R341NC

FB171A/600OHM/0603

R143220/J/0402

2 1

R16056K/F/0402

R343NC

C329NC

R3390/J/0402

C921N/50V/0402

1

2

C4060.1U/25V/0603

+

-

U10AUTC 3308L

3

21

84

C10956P/50V/0402

TC947U/10V/B

R13447K/J/0402

2

1

R454NC

R132220/J/0402

21


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

OVP

INPUTDC 9V 2.0Aor 1.8A

IOSLATOR

LM311C-003-TX3

LM103-004-TX3DVBT POWER

WDR830 SYSTEM BOARD 02Adapter IN

Custom


Title


Date: Sheet of

DC-JACK-IN

INTBAT+

EXTBAT+OUT

INTBAT+

EXTBAT+OUT

INTBAT+OUT

INTBAT+OUT

TS (18)

INTBAT_DISCHG (21)

BATLIFE_DET(21)

BATDET_SEL(21)

External-BAT (21)

Charging-EN (18)

VIN_SYS

VIN_ADA_BAT

GND_DC

GND_DC

EXTCHG_VCC

GND_DC

VCC3_3

GND_DC

+5V_SYS

GND_DC

VCC_CHG

VIN_ADA_BAT

GND_DC

VCC3_3

GND_DC

+5V_SYS

GND_DC

GND_DC

GND_DC

GND_DC

EXTCHG_VCC

EXTCHG_VCC

+5V_SYS

VIN_SYS

GND_DCEXTCHG_VCC

U16APC558KC

1

2

3

4 5

6

7

8AOUT

AIN-

AIN+

GND BIN+

BIN-

BOUT

VDD

C1730.1U/25V/0603

C283

0.1U/50V

/0603

FB632A/600OHM/0805

J11DCJ-01-BLACK

3

2

1

G1

G2

R199100K/J/0603

F2467004.NR

R3141K/F/0603

C393

10P/50V

/0603

Q55PMBS3904

B

EC

R305

1K/F/0603

R157NC

BAT +BAT -

Temp Sensor

J153P/2.0/VA/WAFER

123

G1

G2

R330

NC 10K/F/0603

MH2MH

1

23

45

6

78

9

R217100K/F/0603

VC110P/50V/0603

R467

4.7K/J/0603

C382

0.1U/50V

/0603

C392

10P/50V

/0603

R219100K/F/0603

R4641K/F/0603

R150100K/F/0603

D16NC

A K

FB592A/600OHM/0805

R1471K/F/0603

Q22RSQ030P03

1

3

452

6

C14410U/16V/1206

R198100K/F/0603

R168100K/F/0603

Q20PMBS3904

B

EC

R4611.5K/F/0603

R30227K/F/0603

Q56PMBS3904

B

EC

R202100K/F/0603

TP1381

Q57RSQ030P03

1

3

452

6

R1481K/F/0603

Q39PMBS3904

B

EC

R473NC

R463NC 100K/J/0603

R466

82K/J/0603

Q19PMBS3904

B

EC

Q44

NC PMBS3904

B

EC

TP1791

R220

100K/F/0603

Q43

PMBS3904

B

EC

R331

8.2K/J/0603

Q40RSQ030P03

1

3

452

6

R2210/J/0603

FB622A/600OHM/0805

D28UDZ6.8B

AK

D11UDZ13B

AK

R315

1K/F/0603

R46515K/J/0603

TP1411

R307100K/F/0603

J174P/1.25/RA/WAFER

G1

G2

4321

U17 NC7SB3157

6

5

1

2

34

S

VCC

B1

GND

B0A

C1780.1U/25V/0603

D12RB051L-40

A K

R203

100K/J/0603

P61

R4790/J/0402

TP1781

FB642A/600OHM/0805

R46282K/J/0603

R2150/J/0603

R218100K/F/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

WDR830 SYSTEM BOARD 02+3.3V & +1.45V

B


Title


Date: Sheet of

+3.3V_FLASH +3.3V_D

+3.3V_SYS

+3.3V_V

+3.3V_SD +3.3V_PLL

+3.3V_SYS

+3.3V_RF

GND_POWER GND_POWER

+5V_SYS

GND_DC+1.45V

GND_DC

GND_POWER

+3.3V_USB

GND_POWER

+3.3V_AVD

+3.3V_DAC

GNDV

+3.3V_SYS

GND_POWER

GND_RF

GND_POWER

GND_POWER

+3.3V_tuner

GND_DC

R311100K/F/0603

C39410U/6.3V/1206

TC3547U/6.3V/A

12C67

0.1U/50V/0603

FB651A/600OHM/0603

C1660.1U/50V/0603

FB311A/600OHM/0603

C417100P/50V/0603

C30310U/6.3V/1206

L62.2UH/1A

R18568K/F/0603

C2230.1U/50V/0603

TC3647U/6.3V/A

12

FB401A/600OHM/0603

FB161A/600OHM/0603

FB411A/600OHM/0603

R206300K/F/0603

R304100K/F/0603

TC2247U/6.3V/A

12

C2550.1U/50V/0603

C3220.1U/50V/0603

C3950.1U/50V/0603

FB281A/600OHM/0603

FB521A/600OHM/0603

TC2447U/6.3V/A

12

TC3747U/6.3V/A

12

C2450.1U/50V/0603

TC2947U/6.3V/A

12

C3210.1U/50V/0603

C297NC

R1840/J/0603

FB241A/600OHM/0603

C2530.1U/50V/0603

C16510U/6.3V/1206

L72.2UH/1A

C16110U/6.3V/1206

C3750.1U/50V/0603

C13310U/6.3V/1206

TC2847U/6.3V/A

12

TC347U/6.3V/A

12

C2941U/16V/0603

C29010U/6.3V/1206

R190300K/F/0603

FB251A/600OHM/0603

U14

MP2109DQ

1

2

3

4

5 6

7

8

9

10

11

EN1

FB1

IN2

GND2

SW2 EN2

FB2

IN1

GND1

SW1

EP

AD

R208200K/F/0603

TC2647U/6.3V/A

12

C2050.1U/50V/0603

FB301A/600OHM/0603

C160100P/50V/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

H:ActiveL:OFF

WDR830 SYSTEM BOARD 02+5V

A4


Title


Date: Sheet of

SYS-ON-OFF (20)

+5V_SYS

+5V_M

+5V_AUD

+5V_D

+5V_RF

GND_POWER

VIN_SYS

GND_DC

GND_DC GND_DC

GND_RF

+5V_SYS

GND_DC

-5V_SYS

GNDM

+5V_Spe

+5V_Spe

GND_DC

GND_DC

C4160.1U/50V/0603

R4880/J/1206_R

C3961U/16V/0603

U15

MP2307

8

1

2

3 4

5

6

7

9

SS

BS

IN

SW GND

FB

COMP

EN

gnd

FB321A/600OHM/0603

D14B240A-13-F

AK

R4600/J/0603

TC2747U/10V/B

12

L922UH/2.6A

TC3947U/10V/B

12

VC4NC

C14510U/35V/1206

C176NC

R204

10K/F/0603

FB191A/600OHM/0603

R201

43K/F/0603

C40010U/10V/1206

C156

1N/50V

/0603

C29810N/50V/0603

C2240.1U/50V/0603

FB662A/600OHM/0805

R1917.5K/F/0603

C860.1U/50V/0603

L15

NR6012T/22UH/760mA

C2210.1U/50V/0603

TC1647U/10V/B

12

C2620.1U/50V/0603

C146NC

TC1947U/10V/B

12

C175

10U/10V/1210

C39710U/10V/0805

D27BAT54SW

J

K

A

C1403.3N/50V/0603

FB261A/600OHM/0603

C174

10U/10V/1210

+

D29RLS4148N

AK

C39910U/10V/0805

C4010.1U/50V/0603

C39810U/10V/0805

C41510U/35V/1206


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

123

L:FULL CHARGEH:HALF CHARGE

WDR830 SYSTEM BOARD 02Charger

A4


Title


Date: Sheet of

TSCELL_SEL

TIME_TER_CTRLBAT_CURRENT

PRE-CHG

CHARGE

FAST_CHGTS (15)

BATFAIL_DET(24)

Charging-EN (15)

VTSB

VCC_CHG

EXTCHG_VCC

EXTCHG_VCC

VTSB

GND_DC

+5V_SYS

EXTCHG_VCC

TP118

1

C970.1U/25V/0603

R170

22K/F/0603

C107

10U/35V

/1210

U12BQ24103RHLR

1

23456789

10 11

1213141516171819

20

21O

UT

STAT1ININPGVCCTTCISET1ISET2

VSS

VTSB

TSCELLS

BATSNS

CEPGNDPGNDSTAT2

OU

T

21

R181100K/F/0603

C1280.1U/25V/0603

R412

0/J/0603

R178 100K/F/0603

R17722K/F/0603

R175

15K/F/0603

R18210K/F/0603 Q23

PMBS3904B

EC

L510UH/1.14A

C9610U/16V/1206

C106

10U/35V

/1210

R176

7.5K/F/0603

R1728.66K/F/0603

C4040.22U/25V/0603

R1590.1/F/1206

C1080.1U/25V/0603

Q212N7002

G

DS

TP1161


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

H:ActiveL:OFFL:RESET

H:NORMAL

H:MUTEL:ACTIVE

L:ActiveH:OFF

WDR830 SYSTEM BOARD 02EXT I/O

A


Title


Date: Sheet of

LD5

LD0

LD4

LD1

LD7

LD3LD2

LD6

LD[0..7]

LCS1

IO_MUTE

MU-TE

DVB_RST

DVB-RST

AVIN_SW

AVIN-SW

PWR-TUNER

PWR_TUNER

PWR-TUNERAVIN-SWMU-TE

DVB-RST

LD[0..7](9,10)

LCS1(9,10)

DVB_RST (6)

IO_MUTE (13)PWR_TUNER (6)

AVIN_SW (13)

+3.3V_SYS

+5V_SYS

+5V_SYS

+5V_SYS

+5V_SYS

+3.3V_SYS

R41 33/J/0603

C3710P/50V/0603

Q11NC

B

EC

TP421

R70NC

R214.7K/J/0603

Q7PMBS3904

B

EC

R311K/J/0603

TP1651

U474HC374DWR

3478

13141718

111

256912151619

2010

D0D1D2D3D4D5D6D7

OCCLK

Q0Q1Q2Q3Q4Q5Q6Q7

2010

R321K/J/0603

Q6PMBS3904

B

EC

R331K/J/0603

C290.1U/25V/0603

R204.7K/J/0603

Q8PMBS3904

B

EC

R28NC

TP501

R3630/J/0603

R224.7K/J/0603

R4934.7K/J/0603

R68NC

TP491


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

H:ENABLEL:DISABLE

WDR830 SYSTEM BOARD 02POWER ON/OFF SWITCH

A


Title


Date: Sheet of

SYS-ON-OFF

POWER-KEY

ON_STOP_OFF(21)

POWER_ON_KEEPER(21)

SYS-ON-OFF (17)

POWER_SWITCH (24)

POWER-KEY (24)

VIN_SYS

VCC5

VCC5

R210K/J/0603

1 2

+

D4RLS4148N

A K

R2610K/J/0805

12

Q3PMBS3904

B

EC

R2547K/J/0603

12

+

D1RLS4148N

A K

R346

4.7K/F/0603

1 2

C330

0.1U/16V/0402

R1910K/J/0603

12

SW1

12

34


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

12MHz XTAL

15 mil

15 mil

15 mil

15 mil

15 mil

15 mil

15 mil

15 mil

15 mil

SERIAL FLASH

MST720A 02LCD BOARD

Custom


Title


Date: Sheet of

CPV

CLK2CLK1

CLK3

SCL_TX

TCON14TCON15

Y1NP

TCON12TCON11

C1NM

Y1NM

TCON10

TCON13

XTAL_OUT

CVBS1P

GPIO0

C1NP

CSN

SDI_EEP_SDASCK_EEP_SCL

SDOXTAL_IN

VGOUTVROUT

VBOUT

VCOMOUTVCOMDC

SDA_RX

CSNSDO

SDI_EEP_SDASCK_EEP_SCL

C1NP

C1NM

Y1NM

Y1NP

CVBS1M

CVBS1P

OEV1

CVBS1M

POWER_ON_KEEPER (20)

STH2 (24)

CLK1 (24)

CPV (24)

OEV1 (24)

OEH (24)

STV2 (24)

CLK3 (24)CLK2 (24)

STH1 (24)

SCL (6,8,9)

CP1_N(22)

CP2_P(22)CP2_N(22)

CP1_FB(22)

CP2_FB(22)

STV1 (24)

VCOMOUT (22)

VR (24)

VCOMDC (22)VB (24)VG (24)

REF_PWM(22)CP1_P(22)

PWM1(25)

FB1(25)

MENU_T (24)5_DIR_KEY (24)

S_Y(9)

AVIN_CVBS(3)

S_C(9)

VOLUME (13)

I2C_INT (9)

SDA (6,8,9)

LED_BRIGHTNESS (23)

BATLIFE_DET (15)

BATDET_SEL (15)

LCD_ON_OFF (23)

ON_STOP_OFF (20)

IR_IN (9,24)

MRST (11)

SCL_TX (24)

SDA_RX (24)

INTBAT_DISCHG (15)

External-BAT (15)

AVDD_MPLL

VDDP

VCC5

VCC3_3

VDDC2 VDDPAVDD_DAC

AVDD_OPLL

AVDD_ADC

GND_A

AVDD_PWM

AVDD_CCFL

AVDD_GMC

VCC5

VCC5

VDDC1

AVDD_PWM

GND_A

GND_A

GND_A

GND_A

GND_A

GND_A

GND_A

VCC5

R408

75/F/0402_R

TP150 1

C28

610

0P/5

0V/0

402

C130 0.1U/25V/0603

C281

1U/16V/0603

C10

20.

1U/1

6V/0

402

C113

470P/50V/0603

C149

1U/16V/0603

U19

MX25L512

1234 5

678CE#

SOWP#VSS SI

SCKHOLD#

VDD

RN2

33/J/8P4R/2010

1234

8765

C143 0.1U/16V/0402

R374 0/J/0402

R209 4.7K/J/0402

C162

10U/10V/1206

R481 2.2K/J/0603

R200 4.7K/J/0402

R295 10/F/0603

X1 12MHZ

C280

0.1U/16V/0402

C150 0.1U/16V/0402

C124

470P/50V/0603

R173 13/F/0402

C279

1U/16V/0603

R192 0/J/0402TP149 1

R296 10/F/0603

R180 0/J/0402

C27

5

0.1U

/16V

/040

2

R193

100K/F/0603

C153

0.1U/16V/0402

R187 13/F/0402

R183 33/F/0402

R197 100K/F/0603

R409

75/F/0402_R

R373 0/J/0402

R195 0/J/0603

R212 100/F/0402

R413 0/J/0402

C125 0.1U/25V/0603

R186 62/F/0402

C274 0.1U/16V/0402

R483 0/J/0603

RN4 33/J/8P4R/20101234

8765

C99 0.1U/16V/0402

R174

62/F/0402

C137 0.1U/25V/0603

TP140 1

R210 0/J/0402

R167 0/J/0402

C157

0.1U/16V/0402

R152

1M/F/0603

R213

2K/F/0402

R294 10/F/0603

R162 62/F/0402

C291 0.1U/16V/0402

R188

62/F/0402

C101 20P/50V/0402

R153 4.7K/J/0402

R306 33/F/0402

C112 0.1U/25V/0603

R372 0/J/0402

C28

810

0P/5

0V/0

402

R189 0/J/0402

C277

0.1U/16V/0402

C305

1U/16V/0603

R154

4.7K/J/0402_R

C28

90.

1U/1

6V/0

402

C117 0.1U/25V/0603

C170

0.1U/16V/0402

C100 20P/50V/0402

R489

4.7K/F/0402_R

R214

2K/F/0402

C169

0.1U/16V/0402

R165 13/F/0402

TP146 1

C121 0.1U/25V/0603

C10

30.

1U/1

6V/0

402

TP135 1

LED

DRIV

ER

PWM POWER AND CHARGE PUMP

U13

MST720A

123456789

10111213141516171819202122232425

26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50

51525354555657585960616263646566676869707172737475

767778798081828384858687888990919293949596979899100

AVSS_ADCVCLAMPVRMVRPAVDD_ADCC1NPC1NMYS1NPYS1NMCVBS1PCVBS1MAVDD_GMCVIN_FBOLPZIFBVFBAVDD_SARAVSS_SARAVSS_CCFLAVDD_CCFLQ2Q1VDDC1AVSS_PWMAVDD_PWM

PW

MO

UT2

FB2

SE

NS

EN

2P

WM

OU

T1FB

1S

EN

SE

N1

CP

2_FB

CP

2_N

CP

2_P

CP

1_FB

CP

1_N

CP

1_P

RE

F_P

WM

PG

OO

DS

AR

0S

AR

1S

AR

2S

CK

SD

IS

DO

CS

NP

WM

4DIN

TS

DA

SC

L

POWER_ON_RSTTESTINPWM2DPWM1DRESET

GPIO2/P02GPIO0/P00GPIO1/P01

GNDP1VDDP1TCON1TCON2TCON3TCON4TCON5TCON6TCON7TCON8TCON9

TCON10TCON11TCON12TCON13TCON14TCON15

VD

DP

2G

ND

P2

INTO

UT

RO

M_E

NV

DD

C2

GN

DC

AV

SS

_OP

LLA

VD

D_O

PLLVR

AV

SS

_DA

C1

VG

AV

DD

_DA

C1

VB

AV

SS

_DA

C2

VR

EM

_DA

CV

RE

P_D

AC

VC

OM

DC

VC

OM

OU

TA

VD

D_D

AC

2X

TALO

UT

XTA

LIN

VS

YN

CIN

HS

YN

CIN

AV

SS

_FS

CP

LLA

VD

D_M

PLL

R410 0/J/0402

C180

0.1U/16V/0402

R171 62/F/0402

RN1 33/J/8P4R/20101234

8765

C104

0.1U/16V/0402

R490

4.7K/F/0402_RR211 100/F/0402

R205 47K/J/0402

RN3 33/J/8P4R/20101234

8765

R308

33/F/0402

C27

60.

1U/1

6V/0

402

C134

470P/50V/0603

C28

710

0P/5

0V/0

402

R196 100K/J/0402

R166

62/F/0402


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

VGH

VGL

10mil

10mil

VGL,VGH,VCOM 02LCD BOARD

Custom


Title


Date: Sheet of

OP1 VCOM

VCOMOUT(21)

CP1_P(21)

CP2_P(21)REF_PWM(21)

CP2_FB (21)

CP1_N(21)

CP2_N(21)

CP1_FB (21)

VCOM (24)

VCOMDC (21)

VCC_N4_5

VCC5

VCC5VCCP_VCOM

VCC15_VGH

VCCN10_VGLOUT

R321

20K/F/0603

R431

100K/F/0603

C316

0.1U/16V/0402

C314

0.1U/16V/0402

R287

12K/F/0603

D22BAT54SW

J

AK

R326 0/J/0402

R429 4.7K/F/0603

R430 4.7K/F/0603

C317

10U/16V/1206

C306

0.1U/16V/0402

C307

0.1U/16V/0402

C301

0.1U/16V/0402

C311

0.1U/16V/0402

C312

0.1U/16V/0402

R427 560/F/0603

R318

30K/F/0603

D23

BAT54SW

J

KA

C318

0.1U/16V/0402

C310

0.1U/16V/0402

D21BAT54SW

J

AK

FB0805

L14 SBK201209T-800Y-312

C299

0.1U/16V/0402

R319

220K/F/0603

C380

10U/16V/1206

C302

10U/16V/1206

C308

0.1U/16V/0402

C31

30.

1U/1

6V/0

402

C309

0.1U/16V/0402

D18

BAT54SW

J

KA

D20BAT54SW

J

AK

R428

4.7K/F/0603

R327

15K/F/0402

R426 4.7K/F/0603

R320

10K/F/0402

C379 10U/16V/1206

R323

270K/F/0603

R424

0/J/0603

U11

UTC3308L

1234 5

678OUT1

IN1-IN1+GND IN2+

IN2-OUT2

V+

R425 4.7K/F/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

20V, 100mA LED Backlight

Iout = Vbrt / (3 x R128)

GND_DC

GND_DC

GND_DC

GND_DC

GND_DC

GND_DC

GND_DC

LED POWER DRIVER

LCD POWER DRIVER

WDR830 SYSTEM BOARD 02LCD&LED POWER DRIVER

Custom


Title


Date: Sheet of

LCD_ON_OFF(21)

LED_FB (24)

LED_BRIGHTNESS (21)

LCD_ON_OFF(21)

VCC12

VCC_LED

VIN_SYS

GND_A

VDD_LCDVCC5

VEE_LCD

D26

UDZSTE_17_24BAK

C332

10U/16V/1206

FB331A/600OHM/0603

R351

100K/J/0603

R437

NC

C260

10U/10V/1206

Q36RSR020P03

G

DS

R362 4.7K/J/0603

Q25

PMBS3904

B

EC

R352

100K/J/0603

R349 200K/J/0603

R438

0/J/0603

L12

CBC3225/4.7UH/1A

L16NC

R435

3/F/0805

R439165K/F/0603

R281

4.7K/J/0402

C333

2.2U/25V/1206

R358

10K/J/0603

C335

0.1U/50V/0603

Q50RSR020P03

G

DS

U24

MP1542

1

2

3

4

56

7

8

9

COMP

FB

EN

GN

D

SWIN

FSEL

SS GN

D_T

R433

100K/F/0603

FB341A/600OHM/0603

D24

B140

A K

R357

0/J/0603_R

R43

63/

F/08

05

C261

0.1U/25V/0603

C334

10U/35V/1210

C336

10N/50V/0603

C3372.2N/25V/0603

R194

100K/J/0603

Q35

PMBS3904

B

EC


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

10mil

GND_DC

Connector 02LCD BOARD

A4


Title


Date: Sheet of

GND_A

GND_DCMENU_T_TGND

POWER-KEY

LED_FB

EXTCHG_VCC_T

VCC_LED_T

MENU_T_T

VB_T

VDD_LCD_T

CLK2_T

STH2_T

VCOM_T

CPV_TSTV2_TSTV1_T

VCCN10_VGLOUT_T

UD_T

MENU_T

POWER_SWITCH

MENU_T

POWER_SWITCH

BOTMRST

POWER-KEY

BOTMRST

VCC_LED_T

LED_FB_T

5_DIR_KEY_T

IR_IN_TVCC5_T

VEE_LCD_TVB_T

VG_TVR_T

CLK1_TCLK2_T

CLK3_TSTH1_T

STH2_T

MOD_TVCOM_T

OEV1_TCPV_T

STV2_TSTV1_T

VCCN10_VGLOUT_T

OEH_T

VCC15_VGH_T

VDD_LCD_T

VCC15_VGH_T

OEV1_T

L_R_T

OEH_T

STH1_TCLK3_T

CLK1_T

MOD_T

L_R_T

VR_TVG_T

VEE_LCD_T

5_DIR_KEY_T

BATFAIL_DET_T

IR_IN_T

EXTCHG_VCC_T

LED_FB_T

UD_T

BATFAIL_DET_T

VCC5_T

VB(21)

CLK3(21)STH1(21)

OEV1(21)

CLK1(21)

STH2(21)

VG(21)

CLK2(21)

CPV(21)

STV1(21)

OEH(21)

STV2(21)

VR(21)

VCOM(22)

SDA_RX (21)

SCL_TX (21)

POWER_SWITCH (20)POWER-KEY (20)

LED_FB(23)

MENU_T (21)

BOTMRST (11)

IR_IN(9,21)5_DIR_KEY(21)MENU_T(21)

BATFAIL_DET(18)

VDD_LCD

VEE_LCDGND_A

VCC15_VGHVCCN10_VGLOUT

VCC5

VCC_LED

VDD_LCD

VCC5

EXTCHG_VCC

GND_POWER

GND_POWER

FB51 1A/390OHM/0603

TP1241

C21

20P

/50V

/040

2

C17

220

P/5

0V/0

402

TP231

R360 4.7K/J/0402

TP1471

C373 1U/16V/0603

C364 20P/50V/0402

TP1331

R400 0/J/0402

TP41

C350 20P/50V/0402

R380 0/J/0402

TP1291

R402 0/J/0402

R396 0/J/0402

R388 0/J/0402

C13

220

P/5

0V/0

402

C14

720

P/5

0V/0

402

VC3

NC

C361 20P/50V/0402

TP1341

R391 0/J/0402

TP1371

C366 20P/50V/0402

C363 20P/50V/0402

J12

PANEL CON

123456789

1011121314151617181920212223242526

2930

4647

27

31

28

363738

35

41

3940

4243

323334

4445

GND1VCC1VGLVGHSTRSTLCKVU/DOEVVCOM1VCOM2L/RMODOEHSTHLSTHRCPH3CPH2CPH1VCC2GND2VRVGVBAVDDAVSS

VCC5IR_IN

G1G2

GND_P1

5DIR_KEY

GND_P2

GND_P3GND_P4GND_P5

GND_P9

GND_P6

LED_FB1LED_FB2

VCC_LED1VCC_LED2

EJECTLED_PLED_R

GND_P7GND_P8

TP1451

C359 20P/50V/0402

C22

20P

/50V

/040

2

R392 4.7K/J/0402

C15

520

P/5

0V/0

402

C13

520

P/5

0V/0

402

C358 20P/50V/0402

TP1261

C13

920

P/5

0V/0

402

J3

SWITCH CON

4321

5P_SW2P_SW1MENU

GND

REST

C13

820

P/5

0V/0

402 C

119

20P

/50V

/040

2

C11

020

P/5

0V/0

402

R401 0/J/0402

C13

620

P/5

0V/0

402

C15

420

P/5

0V/0

402

J13DEBUG CON

4321

SDA_RXSCL_TX

DGND+5V

C356 20P/50V/0402

C372 1U/16V/0603

C371 20P/50V/0402

C24

20P

/50V

/040

2

TP1171

TP1641

TP1671

C11

620

P/5

0V/0

402

TP1601

C352 20P/50V/0402

TP1281

C368 1U/16V/0603

TP1611

R378 0/J/0402

R376 0/J/0402

R387 0/J/0402

C13

120

P/5

0V/0

402

R377 0/J/0402

C11

520

P/5

0V/0

402

R381 0/J/0402

C10

520

P/5

0V/0

402

C360 20P/50V/0402

TP1361

FB46 1A/390OHM/0603

TP1221

VC2NC

C12

020

P/5

0V/0

402

R385 0/J/0402

TP1581

TP1441

R389 0/J/0402

TP1211

TP1801

R361

0/J/0402

TP101

C343 20P/50V/0402

TP1311

R386 0/J/0402

C15

820

P/5

0V/0

402

C23

20P

/50V

/040

2

R383 0/J/0402

TP1321

R399 0/J/0402

TP1821

C370 20P/50V/0402

R403 0/J/0402

C369 1U/16V/0603

C14

820

P/5

0V/0

402

TP1681

C362 20P/50V/0402

TP1521

R398 0/J/0402

C365 20P/50V/0402

TP1271

C355 20P/50V/0402

TP341

TP1481

C12

720

P/5

0V/0

402

R394 0/J/0402

TP1831

C357 20P/50V/0402

C14

220

P/5

0V/0

402

TP1621

C354 20P/50V/0402

C349 20P/50V/0402

C351 20P/50V/0402

R390 0/J/0402

C353 20P/50V/0402

C11

120

P/5

0V/0

402

C14

120

P/5

0V/0

402

TP1511

R404 0/J/0402

R379 0/J/0402

C12

320

P/5

0V/0

402C

168

20P

/50V

/040

2

C12

220

P/5

0V/0

402

FB45 1A/390OHM/0603

TP1191

TP321

C15

220

P/5

0V/0

402

TP1811

R395 0/J/0402

TP1201

TP1551

R382 0/J/0402

R393 0/J/0402

C344 20P/50V/0402

C12

620

P/5

0V/0

402

R397 0/J/0402

C367 20P/50V/0402

TP1231

TP1251R384 0/J/0402


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

+2.5V

-5V

OUTPUT CONTROL by M720

Power 02

M720 POWERCustom


Title


Date: Sheet of

PWM1(21)

FB1 (21)

VCC5VCC2_5

VCC5AVDD_DAC

AVDD_PWM

AVDD_CCFL

AVDD_GMC

VDDP

VCC3_3

AVDD_MPLL

VCC2_5 AVDD_OPLL

AVDD_ADC

VDDC1

VCC2_5VDDC2

VCC_N4_5

+3.3V_SYS

+5V_SYS

GND_DC

GND_DC

GND_DC

GND_DC

GND_DCGND_DC

GND_A

GND_A

R289 0/J/0603

C319

0.1U/25V/0603

L10

CBC2016/22UH

R293 4.99/F/0603

FB55BK1005HS330

R292 4.99/F/0603

R303

NC

R310 30/F/0402

TC11

100U/6.3V/B

D17 BAT54SW

J

K

A C295

10U/6.3V/0805

R299 4.99/F/0603D19

B0520LW

AK

R316

470/F/0402

R317

510/F/0402

R301 4.99/F/0603

C315 0.1U/25V/0603

FB56BK1005HS330

Q42RSR020P03

G

DS

C300

1U/16V/0603

R312 2/F/0603

C320

10U/10V/0805

TC31

47U/6.3V/B_R

R324

33/F/0402

C296

NC

C304

0.1U/25V/0603

R313 0/J/0603

TC30

NC

R300 2/F/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

30mA

02

Video bufferA


Title


Date: Sheet of

8380_CVBS(9)

AVOUT_CVBS (3)

+3.3V_SYS

NETGNDV

GNDV

GNDVGNDVGNDV

GND_DC

GNDV

C4030.1U/50V/0603

C33922P/50V/0603

FB541A/600OHM/0603

C33810U/10V/0805 R364

1K/F/0402

2

1

C4020.1U/50V/0603

C34147P/50V/0603

TC3847U/6.3V/A

12

C34222P/50V/0603

Q51

PMBS3904B

EC

Q52PMBS3906

CE

B

R371100/F/0402

2

1

R36875/F/0402

2

1

C418100P/50V/0603

FB431A/600OHM/0603

R491 0/J/0603

L132.2UH/50mA/2520


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

GND_DC

bridge bridge

bridge

WDR830 Main Board 02A427 28Tuesday, February 06, 2007

Title


Date: Sheet of

GND_SIGNAL

GND_SIGNAL

GNDM

GND_DC

GND_RF

GND_SIGNAL

GND_POWERGNDV

GND_SIGNALGNDV

GND_POWER

GND_SIGNAL

GND_POWER GND_RF

GND

GND_POWER GND_SIGNAL GND_DC

GND_SIGNAL GND_DC

GND_DC

GND_SIGNALGND_SIGNAL

GND_A

GND_A

TBD28NC

TBD15NC

R298 0/J/0603

TBD25NC

R443 0/J/0603_R

TBD23NC

R4850/J/0603

R442 0/J/0603_R

R325 0/J/0603

TBD31NC

TBD32NC

P11

TBD29NC

P5

1

R4840/J/0603

TBD22NC

TBD26NC

R446 0/J/0603_R

TBD10/J/0805

TBD27NC

TBD2NC

TBD3BCF-35320A

TBD24NC

TBD17NC

TBD19NC

R4860/J/0603

R444 0/J/0603_R

R440 0/J/0603_R

TBD18NC

TBD30NC

TBD16BCF-35320A

R441 0/J/0603_R

TBD40/J/0805

TBD60/J/0805

R445 0/J/0603_R

TBD8BCF-35320A

TBD20NC

TBD21NC

P2

1

R4750/J/0603

P31

R4800/J/0603_R

R4760/J/0603


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

FUNCTION

AUX4

AUX7

IR

AUX0

System setup configuration storageProgram storage using 16Mbit Flash

DC PWR PLUG DET

24C04 SERIAL EE

I2C DATAI2C CLOCK

AUX5 AVIN CABLE PLUG DET

AUX3

128MBit SDRAM16Mbit EPROM/FLASH

I2C INTERRUPT

TDR086L LIMIT SWITCH

SPARE

Single chip processor that handles all system control, DVD decoding and servo control.

AUX2

ES8380FCACHIP

System Configuration

Data storage and frame buffer using 1 pc of 4Mx16 SDRAM

AUX1

FUNCTION

AUX6

AUXx

I/O expandFLASH/MOTOR DRIVE(FG CONTROL)ROM/FLASH

LCS0#LCS1#

LCSx#NC

LCS2#

FUNCTION

LCS3#

Revision History

1.Change AVIN cable plug detect by softwareRev-B

Ver-A

5.Change NIM module connector package4.Change docking and int/ext BAT connector package, battery life detect by M720, add subtraction for battery life detect

Prototype design.

3.Del D1,D2,D3,D4, connect net (LOAD+&LOAD-)2.Add coaxial digital output

6.Change motor drive FG to +3.3V7.Change EEPROM pull high to +3.3V8.Change ES8380 AUX function,9.Change romter connector package to FPC 36 pin10. Connect RESET to M720, H/W reset buttom11. Del input R,C filter of TPA6011A4, modify power on mute, add headphone mute circuit12. Add coaxial digital audio output buffer13.Change +1.45V,+3.3V power solution14.Add extend I/O output +3.3V->5V buffer15. seperate ground to motor ,pickup(RF)

Rev-C1.Add R3292.Change NET NAME( ESS8380-97->+3.3V_USB, ESS8380-177->+3.3V_AVD3.Add FB40,FB41,C321,C322,TC28,TC29

1.change footprint for assemblyJ5->LM312004TF13J15->LM311C003TX3J17->LM103004TX3

Rev-F

2. Change U15->MP2307 for power supply large current

WDR830 SYSTEM BOARD FHISTORY

A3


Title


Date: Sheet of


55

4

4

3

3

2

2

1

1

D D

C C

B B

A A

Power CON

NIM Module

System Board CON

+3.3V +5V

DC-DC+1.8V

+9V

DVBT FBlock Diagram

A

1 5Monday, January 08, 2007

Title

Size

philips pet830 pet835

Documents

press setup key

set playpause key

usb drive

main set

press return key

power supply

ok key

usb port