0 energy and fuels from biomass and waste prof.dr.ir. gerrit brem energy technology onderzoeksdag...

1

Energy and Fuels

from Biomass and Waste

Prof.dr.ir. Gerrit Brem

Energy Technology

Onderzoeksdag KIVI NIRIA, 19th of May 2011, Enschede

2

Biomass Research at University of Twente

Faculty of Engineering

Faculty of Science

Faculty of Management and Governance

Biomass is spearhead of UT!

3

Energy Technology group

Faculty of Engineering

Since 2000 (2009)

15 fte staff, PhD and post-docs

Academic and industrial network

Well-equipped laboratory

4

Laboratory “Kleinhorst”

5

Energy Technology group

Combustion of solid fuels

“Energy from biomass and waste”

Production of sustainable fuels (liquid, gas and solid)

“Fuels from biomass and waste”

6

Combustion of solid fuels

Coal fired power plants

“biomass co-firing”

Waste combustion

7

Co-firing of biomass in power plants (combustion)

Focus on:

Boilers with Ultra Supercritical steam conditions

High ratio of biomass co-firing

Slagging and fouling mechanisms

Development of modelling tools

Sponsors: TSA, KEMA

8

Co-firing of biomass in power plants (combustion)

9

Co-firing of biomass in power plants (fouling)

10

BioOxyfuel

Torrefied Biomass Combustion under Oxy-fuel Conditions in Coal Fired Power Plants

Combustion characteristics

Drop Tube Furnace

Sponsors: STW, NVV, TSA, KEMA

11

Waste combustion

12

Ignition and combustion of waste on a grate

• Ignition by flame radiation

• Self-ignition

• Mathematical modelling

• Reversed combustion concept

13

AVI pilot-plant

14

Combustion plant

Operator

Waste

Disturbancesby fluctuatingcomposition

Smart Sensor

Heating value+

Fouling rate

Smart sensors for combustion and fouling

Flue gasBoiler

Steam temperatures

Gas concentrations

15

Fuel production from Biomass

Flash pyrolysis

Gasification

Torrefaction

16

PYROLYSISREACTOR

Biomass

Heat

condenser

Char Separation

Gas

Bio-oil

Char

Flash pyrolysis of biomass

Wood pyrolysis on lab scale - movie

18

PyRos pilot-plant with 30 kg/h biomass feed

PYROLYSISREACTOR

Biomass

Heat

condenser

Char Separation

Gas

Bio-oil

Char

Near-future applications for pyrolysis oil

20

Algae and scrap tyres

Oil from car tyres Oil from algae

21

Gasification in supercritical water

Wet biomass

Process conditions: 600 °C and 300 bar

Production of a hydrogen or methane rich gas

Process integrated reactor

CO2 separation

C

Heat exchanger

supercritical reactor

high P gas/liquid separator

feedstock

600 °C 300 bar

low P gas/liquid separator

Torrefaction

Biomass is wet and bulky

Biomass sources are distributed

Pretreatment required!

Torrefaction process

On-site preparation of biomass by drying, milling and torrefaction (no external energy requirement)

Torrefaction: roasting of biomass at 250°C

• Friable and less fibrous• Hydrophobic• Preserved• Reduced contaminations• Homogeneous• Higher heating value

24

OCRI – Bioenergy with provincie Overijssel

Overijssels Centre for Research and Innovation

Grant of 2,5 Meuro

Cooperation with local industries

9 postdocs (UT)

Research projects:

> Catalytic pyrolysis for high-value fuels

> Combustion of pyrolysis oil in gas turbines

> Feedstock engineering

25

Thanks for your attention

Prof.dr.ir. G. BremUniversity of TwenteEnergy Technology (CTW)P.O.box 2177500 AE EnschedeThe Netherlands

T: +31 53 489 2561 (2530)M:+31 6 5328 6744

e-mail:  g.brem@utwente.nl www.thw.ctw.utwente.nl